Weekly - Wascom EMERALD W75ES Operating & Maintenance Manual

Maintenance
Preventive maintenance has been reduced to a
minimum by the careful design of reliable compo-
nents and material.
However, the following measures should be
taken at regular intervals and in proportion to the
hours of service.
IMPORTANT!
Make certain that all electrical power to
the machine is shut off before removing
top or rear panels.
Daily
• Check the door lock and interlock before
starting operations.
• The soap supply box should be cleaned at the
end of each working day as follows:
- Use a spatula to scrape loose any deter-
gent which may have stuck on the inside of
the dispenser.
- Flush the loosened detergent with warm
water.
- Wipe dry and leave lid open.
• Check that the drain valve does not leak and
Fig.
that it opens properly.
82
• Check that the door does not leak. Clean
residual detergent and foreign matter from the
door gasket.
• Wipe the outside of the machine.
• When the machine is not in use, leave door
slightly open to allow moisture to evaporate.

Weekly

• Remove the top panel and carefully clean
the rubber gasket on top of the soap box so it
tightly seals to the top panel. If you do not
maintain a tight seal you risk suds overflow onto
the door lock.
Every three months
• Remove the hose from the drain connection
Fig.
and clean the inside of the drain valve.
83
• Remove the rear panel of the machine and
check that the V-belt of the wash motor is
undamaged and correctly tensioned.
Maintenance
82
83
55
1833
1207