Recharging The Battery - KTM 450 SX-F Owner's Manual

MAINTENANCE WORK ON CHASSIS AND ENGINE
x

Recharging the battery

8.81
Warning
Risk of injury Battery acid and battery gases cause serious cauterization.
–
Keep batteries out of the reach of children.
–
Wear suitable protective clothing and goggles.
–
Avoid contact with battery acid and battery gases.
–
Keep the battery away from sparks or open fire. Charge only in well ventilated rooms.
–
In the event of skin contact, rinse with large amounts of water. If battery acid gets in the eyes, rinse with water for at least
15 minutes and contact a doctor.
Warning
Environmental hazard Components and battery acid are a danger to the environment.
–
Do not dispose of batteries in normal household waste. Take defective or used batteries to a battery recycling operator.
Warning
Environmental hazard Problem materials cause environmental damage.
–
Dispose of oil, grease, filters, fuel, cleaning substances, brake fluid, batteries, etc. according to regulations.
Info
Even if there is no load on the battery, it loses power every day.
The charge state and the type of charge are very important for the service life of the battery.
Fast recharging with a high charge current shortens the battery's service life.
If the charge current, the charge voltage and the charge time are exceeded, electrolyte escapes through the breathing holes. The
battery capacity is then reduced.
If the battery is discharged from starting, it must be recharged immediately.
If it stands for a long time in a discharged state, the battery becomes over-discharged and sulfated, and then it is destroyed.
The battery is maintenance-free, i.e., the acid level does not have to be checked.
–
Place the battery in the battery holder.
450 XC-F, 505 XC-F
4Ah battery (YTX5L-BS) (
450 SX-F, 505 SX-F
Conditions
External temperature: ≥ 10 °C ( ≥ 50 °F)
3Ah battery (YTX4L-BS) (
Conditions
External temperature: ≤ 10 °C ( ≤ 50 °F)
4Ah battery (YTX5L-BS) (
–
Reconnect the rubber band
–
Attach the plus cable and replace the plus pole cover
–
Attach the minus cable
–
Mount the seat (
–
Switch off all power-consuming components and switch off the engine.
–
Remove the seat (
–
Disconnect the minus (negative) cable of the battery to avoid damage to the
motorcycle's electronics.
–
Connect the battery charger to the battery. Switch on the battery charger.
Battery charger (58429074000)
You can also use the battery charger to test rest potential and start potential of
the battery, and to test the generator. With this device, you cannot overcharge the
battery.
Info
Never remove the lid
400240-10 Charge the battery according to the instructions
76)
76)
76)
.
1
.
3
53)
53)
.
1
51
.
2
on the battery casing.
2