HearthStone Santa Fe 8761 Owner's Manual

HearthStone Santa Fe 8761 Owner's Manual

Gas-fired direct vent heater
Hide thumbs Also See for Santa Fe 8761:

Advertisement

WARNING: If the information in these instructions
is not followed exactly, a fire, or explosion may
result causing property damage, personal injury, or
loss of life.
Do not store, or use gasoline, or other
flammable vapors and liquids near this, or any
other gas appliance!
WHAT TO DO IF YOU SMELL GAS:
Do not try to light any appliance.
Do not touch electrical switches; do not use the
phone in your building.
Immediately call your gas supplier from a
neighbor's phone. Follow your gas supplier's
instructions.
If you cannot reach your gas supplier, call the fire
department.
A qualified installer, service agency, or gas supplier
must perform installation and service. In the
Commonwealth of Massachusetts, all installation of
gas lines and gas fitting shall only be done by a
licensed gas fitter or licensed plumber.
Santa Fe
GAS-FIRED DIRECT VENT HEATER
Owner's Manual
Operation & Installation Guide
READ THIS OWNER'S MANUAL
Operate and maintain this gas heater
according to this instruction manual.
AVERTISSEMENT: Assurez-vous de bien suivre les
instructions donné dans cette notice pour réduire
au minimum le risque d'incendie ou pour éviter tout
dommage matéeriel, toute blessure ou la mort.
Ne pas entresposer ni utiliser d'essence ni d'autre
vaperurs
ou
liquides
voisinage de cet apprareil ou de tout autre appareil!
QUE FAIRE SI VOUS SENTEZ UNE ODEUR
DE GAZ:
Ne pas tenter d'allumer d'appareil.
Ne touchez à aucun interrupteur. Ne pas vous
servir des téléphones se trouvant dans le
batiment où vous vous trouvez.
Appelez immédiatement votre fournisseur de
gaz depuis un voisin. Suivez les instructions
du fournisseur.
Si vous ne pouvez rejoindre le fournisseur de
gaz, appelez le service dos incendies.
L'installation et service doit être exécuté par un
qualifié
installer,
agence
fournisseur de gaz.
(Model 8761)
inflammables
dans
le
de
service
ou
le
Santa Fe Model: 8761
Manual: 6400-40451
Revised: 10/2/08

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the Santa Fe 8761 and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Summary of Contents for HearthStone Santa Fe 8761

  • Page 1 Santa Fe (Model 8761) GAS-FIRED DIRECT VENT HEATER Owner’s Manual Operation & Installation Guide READ THIS OWNER’S MANUAL Operate and maintain this gas heater according to this instruction manual. WARNING: If the information in these instructions AVERTISSEMENT: Assurez-vous de bien suivre les is not followed exactly, a fire, or explosion may instructions donné...
  • Page 2: Service Record

    Hearthstone Quality Home Heating Products, Inc. SANTA FE Model 8761 INFORMATION SHEET Use this page to record all relevant information concerning the purchase, installation, and maintenance of your SANTA FE Gas-Fired Direct Vent Heater. This information will facilitate servicing, purchase of replacement parts, and warranty claims (if necessary).
  • Page 3: Table Of Contents

    Hearthstone Quality Home Heating Products, Inc. SANTA FE Model 8761 ABLE OF ONTENTS ELCOME ..........2 ELCOME Congratulations your purchase Hearthstone’s Santa Fe Gas-Fired Direct Vent ’ ......3 WNER NFORMATION heater. The Santa Fe incorporates the latest in ......... 4...
  • Page 4: Information

    Hearthstone Quality Home Heating Products, Inc. SANTA FE Model 8761 when in the same room as the appliance. Do ERVICE AUTION Any components of the stove removed for not place clothing or other flammable servicing must be replaced before operating. If material on or near the appliance.
  • Page 5: Aily Perations

    5. Turn gas control knob counterclockwise to switches are available for purchase from your “PILOT”. local Hearthstone dealer. Once the thermostat is 6. Push in control knob all the way and hold in. installed and properly adjusted, the desired room Immediately light the pilot with the gas temperature is maintained.
  • Page 6: Nstaller Information

    Santa Fe are damaged, they must be replaced. CAN/CGA B149 Installation Code, which can Hearthstone supplies replacement parts through be obtained from: your local Hearthstone dealer. Do not replace fiber logs, or the embers, with any materials not AMERICAN NATIONAL STANDARDS approved by Hearthstone Quality Home Heating INSTITUTE, INC.
  • Page 7: Tove Imensions Learances To Ombustibles

    Hearthstone Quality Home Heating Products, Inc. SANTA FE Model 8761 Packing List EARTH EQUIREMENT LOOR ROTECTION 1-Santa Fe Gas-fired Heater containing: The Santa Fe can be placed on a non- 5-Decorative Ceramic Logs combustible surface, or wood floor. For 1-Pan Burner placement of the Santa Fe on carpeting, vinyl 1-Owner’s Manual and Warranty...
  • Page 8 Hearthstone Quality Home Heating Products, Inc. SANTA FE Model 8761 Figure 2 - Santa Fe Dimensions 3 1/8" 25 " 21 3/4" LEARANCE TO OMBUSTIBLES 17" max. 2" MIN. 2" MIN. 1" MIN. 14" MIN. 4" MIN. Figure 3 - Rear and side wall clearances The corner clearance for the Santa Fe is 2”, to be measured from the edge of the...
  • Page 9 Hearthstone Quality Home Heating Products, Inc. SANTA FE Model 8761 SPECIFICATIONS: ISTED IRECT EATER Model: 8761-Santa Fe 1 DV Testing Agency: Intertek Testing Services NA, Inc. (ITS) Tested to: ANSI Z21.88- 2002•CSA 2.33-M02 CAN/CGA 2.17 Fuel type Input rating (Btu/hr) 0-2000 ft...
  • Page 10: Enting Nformation

    Hearthstone Quality Home Heating Products, Inc. SANTA FE Model 8761 ENTING NFORMATION There are many configurations of vent installations for your stove. Please review the following pages for the venting installation that works best for you. Note: Vent terminals must not be recessed into...
  • Page 11 Hearthstone Quality Home Heating Products, Inc. SANTA FE Model 8761 Approved Possible Vent TERMINATION locations.
  • Page 12: Pproved Enting Ystem Omponents

    Hearthstone Quality Home Heating Products, Inc. SANTA FE Model 8761 Note: The Standard Horizontal Vent Kit does turn clockwise until the two sections are fully not require a restrictor. locked. Install the 90º elbow in similar fashion. The vent/air intake termination clearances above...
  • Page 13 Hearthstone Quality Home Heating Products, Inc. SANTA FE Model 8761 ENT RESTRICTOR To adjust your restrictor for maximum flame appearance, loosen the Phillips head screw and spin the locator, found on the rear left side of the stove. (Refer to figure 7) Figure 7 II.
  • Page 14 Hearthstone Quality Home Heating Products, Inc. SANTA FE Model 8761 III. V ERTICAL ERMINATION ENTING ONFIGURATIONS -40' maximum system height (without offsets) Figure 8...
  • Page 15 Hearthstone Quality Home Heating Products, Inc. SANTA FE Model 8761 Figure 9 Use a vinyl siding Stand off when installing IV. Horizontal Termination Venting against vinyl siding. Configurations -Horizontal sections require a 1/4" rise every 12" -A minimum of 24" rise is required (with or w/o of horizontal run.
  • Page 16 Hearthstone Quality Home Heating Products, Inc. SANTA FE Model 8761 Approved DV Venting Configurations for Horizontal Termination Figure 10 Conditionally approved for purchased mobile Cet appareil peut être installé dans un maison home installation. This appliance may be préfabriquée (mobile) déjà installée à demeure installed in an aftermarket permanently si les règlements locaux le permettent.
  • Page 17: Connections

    Hearthstone Quality Home Heating Products, Inc. SANTA FE Model 8761 Figure 11 ONNECTIONS The gas supply line connection is made to the Santa Fe’s gas control valve located under the unit on the left side using a 3/8" NPT fitting.
  • Page 18: Eplacing The Lass

    SANTA FE 1 Gas-Fired Direct Vent heater HearthStone Quality Home Heating Products Inc the enamel when loosening the bolt. Pull EPLACING THE LASS To replace the front glass, shut the pilot light off. the door open by grabbing the top edge of Remove the front screw, using the 1/8”...
  • Page 19: Emoval Of Log Set

    Once the Santa Fe is set in place and connected This wool will glow once the unit is running. as described previously, the unit is ready to be lit for the first time. Hearthstone tests each Santa Fe before shipment, so ignition should take place without failure.
  • Page 20: Nitial Djustments

    SANTA FE 1 Gas-Fired Direct Vent heater HearthStone Quality Home Heating Products Inc ILOT IGHT The Santa Fe has a piezoelectric spark igniter (the red or black push button located next to the gas control valve behind the valve access door), which ignites the pilot light by means of a spark at the pilot light assembly.
  • Page 21: Conversions

    SANTA FE 1 Gas-Fired Direct Vent heater HearthStone Quality Home Heating Products Inc Once a year the unit and venting system should be inspected by qualified service personnel to ensure that they are clean, prevent the accumulation of dust, lint and other debris, free of obstruction, safe and in good working condition.
  • Page 22 SANTA FE 1 Gas-Fired Direct Vent heater HearthStone Quality Home Heating Products Inc moment de l’entretien des commandes, étiquetez IRING NSTRUCTIONS Caution: Label all wires prior to disconnection tous les fils avant le débranchement. when servicing controls. Wiring errors can erreurs câblage...
  • Page 23: Arts Ists

    ! Do not substitute Materials. ARNING For replacement parts, or for information about parts or service, contact your authorized Hearthstone retailer. For the name of the authorized retailer nearest to you, visit our website at www.Hearthstonestoves.com, or e-mail us at inquiry@Hearthstonestoves.com.
  • Page 24 ATING ABEL 07044-2...
  • Page 25: Troubleshooting Guide

    TROUBLESHOOTING GUIDE Symptom Possible Cause Corrective Action 1. Pilot will not A. Using the piezo sparker, try to light the pilot. If it will A. Insufficient gas pressure, light. not light, check the inlet gas pressure. air in the pilot line, or dirty or kinked gas line.
  • Page 26 Symptom Possible Cause Corrective Action 3. Pilot burning, no A. Thermostat switch or A. Check thermostat/wiring for proper connections. gas to main burner, wires defective. Place jumper wire across terminals at thermostat. If valve knob in the burner comes on, replace defective thermostat. If not "ON"...
  • Page 27 Symptom Possible Cause Corrective Action 8. Floating flames, A. Potentially dangerous A. Check the appliance input rate and reduce if lazy ill-defined, incomplete combustion due necessary. The air intake/exhaust flow system may be quiet flames, which to incorrect air to fuel ratio too restrictive or blocked (the rate at which the exhaust roll around, (lack of combustion air or...
  • Page 28: Limited Warranties

    Original Purchaser (referred to as the “Stove” for simplicity) against any of the occurrences listed in this document that result from defects in material or workmanship. All obligations of Hearthstone under this document commence on the date the Original Purchaser purchases the Stove (the “Purchase Date”).
  • Page 29 9. A defect in any part of the Stove if the Original Purchaser fails to comply with Hearthstone’s or a Dealer’s request to ship the part or the Stove to Hearthstone or a Dealer, as the case may be.
  • Page 30: Warranty Registration

    Purchaser to either return the defective part, or the entire Stove (if needed), with shipping prepaid, to Hearthstone, or a Dealer, or allow a Dealer to make a service call at the place where the Stove is located. In the event the Original Purchaser refuses to allow a Dealer to make a service call, Hearthstone, or a Dealer, as the case may be, will request that the Original Owner return the defective part, or the entire Stove (if needed), with shipping prepaid, to Hearthstone or a Dealer.

Table of Contents