HearthStone 8323 Owner's Manual
  1. Manuals
  2. Brands
  3. HearthStone Manuals
  4. Indoor Fireplace
  5. 8323
  6. Owner's manual

HearthStone 8323 Owner's Manual

Gas-fired direct-vent heater
Hide thumbs
Table of Contents

Advertisement

Quick Links

WARNING:
FOLLOW
THESE INSTRUCTIONS EXACTLY, IF NOT, A FIRE
OR
EXPLOSION
PROPERTY DAMAGE, PERSONAL INJURY OR
LOSS OF LIFE.
WARNING: DO NOT STORE OR USE GASOLINE
OR ANY OTHER FLAMMABLE VAPORS AND
LIQUIDS NEAR THIS OR ANY OTHER GAS
APPLIANCE.
WHAT TO DO IF YOU SMELL GAS:
Do not try to light any appliance.
Do not touch electrical switches; do not use the phone
in your building.
Immediately call your gas supplier from a phone
outside the structure. Follow your gas supplier's
instructions.
If you cannot reach your gas supplier, call the fire
department or 911.
A qualified installer, service agency, or gas supplier must
perform installation and service of this appliance. In the
Commonwealth of Massachusetts, all installation of gas
lines and gas fittings must be performed by a licensed gas
fitter or licensed plumber.
THE
INFORMATION
MAY
RESULT
CAUSING
GAS-FIRED DIRECT-VENT HEATER
Read This Manual in Its Entirety
Operate And Maintain This Gas Heater
According To This Instruction Manual.
IN
AVERTISSEMENT:
SUIVRE
LES
CETTE NOTICE POUR RÉDUIRE AU MINIMUM LE
RISQUE D'INCENDIE OU POUR ÉVITER TOUT
DOMMAGE MATÉERIEL, TOUTE BLESSURE OU
LA MORT.
AVERTISSEMENT: NE PAS ENTRESPOSER NI
UTILISER D'ESSENCE NI D'AUTRE VAPERURS
OU
LIQUIDES
VOISINAGE DE CET APPRAREIL OU DE TOUT
AUTRE APPAREIL.
QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ:
Ne pas tenter d'allumer d'appareil.
Ne touchez à aucun interrupteur. Ne pas vous servir
des téléphones se trouvant dans le batiment où vous
vous trouvez.
Appelez immédiatement votre fournisseur de gaz
depuis un voisin. Suivez les instructions du
fournisseur.
Si vous ne pouvez rejoindre le fournisseur de gaz,
appelez le service dos incendies.
L'installation et service doit être exécuté par un qualifié
installer, agence de service ou le fournisseur de gaz.
Hearthstone Quality Home Heating Products, Inc. ®
Stowe
(Model 8323)
Owner's Manual
Installation & Operating
Instructions
SAVE THESE INSTRUCTIONS!
ASSUREZ-VOUS
INSTRUCTIONS
DONNÉ
INFLAMMABLES
Stowe Model 8323
Manual: 6400-40449
DE
BIEN
DANS
DANS
LE
R: 6/1/2015

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the 8323 and is the answer not in the manual?

Questions and answers

Related Manuals for HearthStone 8323

Summary of Contents for HearthStone 8323

  • Page 1 L’installation et service doit être exécuté par un qualifié lines and gas fittings must be performed by a licensed gas fitter or licensed plumber. installer, agence de service ou le fournisseur de gaz. Hearthstone Quality Home Heating Products, Inc. ® Stowe Model 8323 Manual: 6400-40449 R: 6/1/2015...

  • Page 2: Hearthstone Quality Home Heating Products, Inc. Stowe 3 Model

    Hearthstone Quality Home Heating Products, Inc. Stowe 3 Model 8323 NOTE ON BATTERY INSTALLATION IN RECEIVER Please refer to pages 31 – 38 of this manual for operation of Maxitrol GV-60 gas control system. The following illustration is intended only to identify component location and receiver removal for installation of the 4 AA batteries included in your stove.
  • Page 3 Use this page to record all relevant information concerning the purchase, installation, and maintenance of your Stowe Model 8323 Direct -Vent heater. This information will facilitate servicing, purchase of replacement parts, and warranty claims (if necessary). Keep your original receipt in a safe place as proof of purchase.

  • Page 4: Table Of Contents

    Hearthstone Quality Home Heating Products, Inc. Stowe 3 Model 8323 Table of Contents ..............................5 PECIFICATIONS …………………………………………………………………………………………………………… .. 6 NTRODUCTION ............................6 AFETY NFORMATION ..........................9 NSTALLATION REPARATION Codes ..................................9 Items Required for Installation ..........................9 Packing List ................................9 Unpacking and Inspection ............................

  • Page 5: Specifications

    Hearthstone Quality Home Heating Products, Inc. Stowe 3 Model 8323 PECIFICATIONS : Gas-Fired Direct-Vent Fireplace Heater Certified for Canada, CSA P.4.1 ISTED Model: Stowe Direct-Vent Gas Fireplace Approved for Mobile Home Installation (see Heater (8323) page 8) Testing Agency: Intertek Testing Services Certified for use by: NA, Inc.

  • Page 6: Introduction

    Brown Enamel 8323-0031NP Oyster Enamel Congratulations on your purchase of the Stowe Model 8323, Gas-Fired Direct-Vent heater. The Read this Owner’s Manual Stowe, by Hearthstone, incorporates the latest in direct vent gas technology, which will provide you Operate and maintain this gas heater according to with clean, efficient heat for years to come.
  • Page 7 SHOULD BE LOCATED OUT OF TRAFFIC AND to operation. Use of any components not supplied by AWAY FROM FURNITURE, DRAPERIES, Hearthstone on the stove voids all warranties. Do not CLOTHING AND FLAMMABLE MATERIALS. substitute components. RAISON TEMPÉRATURES ÉLEVÉES, L’APPAREIL DEVRAIT ÊTRE INSTALLÉ DANS UN Proper Fuel ENDROIT OÙ...

  • Page 8: Mobile Home Installations

    Hearthstone Quality Home Heating Products, Inc. Stowe 3 Model 8323 RECOMMENDED THERE RISK components affect the combustion quality and safety INDIVIDUALS IN THE HOUSE. TO RESTRICT of the heater. Do not replace ceramic logs, the ACCESS TO A FIREPLACE OR STOVE, INSTALL...

  • Page 9: Installation Preparation

    Hearthstone Quality Home Heating Products, Inc. Stowe 3 Model 8323 Pipe sealant approved for use with Installation Preparation propane (LP) (resistant to sulfur compounds). Manual shutoff valve Codes Sediment trap (see page 20) Adhere to all local codes or, in their absence, the...

  • Page 10: Clearances To Combustibles

    Hearthstone Quality Home Heating Products, Inc. Stowe 3 Model 8323 Figure 3 – Front Panel Removal ceramic burner. Open the other boxes and inspect the components. If log, burner or any other component damage is encountered, contact your 3. While holding the glass to the firebox with one dealer for a replacement.

  • Page 11: Clearances To Combustibles

    Hearthstone Quality Home Heating Products, Inc. Stowe 3 Model 8323 and draperies. Do not place clothing and other flammable material on or near the heater. When positioning the unit always maintain adequate clearances around openings into combustion chamber and allow for adequate ventilation.

  • Page 12: Venting Information

    Hearthstone Quality Home Heating Products, Inc. Stowe 3 Model 8323 The corner clearance for the Stowe 8323 is 4”, measured from the edge of the firebox to the adjacent wall. Venting Information Venting Components Starter collar is installed by Hearthstone.
  • Page 13 Installations Steep roofs, nearby trees, or predominantly strong windy conditions can promote poor draft The Stowe 8323 is approved for use with direct vent or down draft conditions. In this event, an chimney conversion kits in masonry or prefabricated increase to the height of the vent may improve solid fuel listed chimneys.

  • Page 14: Minimum Venting Installation Instructions

    Hearthstone Quality Home Heating Products, Inc. Stowe 3 Model 8323 Prefabricated chimneys must be UL103 or ULC Minimum Venting Installation S-629 listed and have a minimum INSIDE Instructions diameter of 6”. Prefabricated chimneys must be listed for the specific manufacturer’s conversion 1.
  • Page 15 Hearthstone Quality Home Heating Products, Inc. Stowe 3 Model 8323 Figure 9 - Components for a Typical Snorkel Installation Figure 10 - Components for a Typical Minimum Horizontal Venting Installation Centerlines shown are approximate. Ensure you dry fit your venting and take a measurement. Pipe dimensions will vary by manufacturer and supplier.
  • Page 16 Hearthstone Quality Home Heating Products, Inc. Stowe 3 Model 8323 Figure 12 - Acceptable Direct Vent Terminal Vent Cap Locations A = Clearance above grade, veranda, porch, deck, H = *Not to be installed within 15 feet (4.5m) above or balcony: 12 inches (30cm) minimum.
  • Page 17 Hearthstone Quality Home Heating Products, Inc. Stowe 3 Model 8323 Figure 13 - Venting Termination Diagram...

  • Page 18: Electrical System Information

    (ATTENTION: AU MOMENT DE L’ENTRETIEN DES COMMANDES, ÉTIQUETEZ TOUS LES FILS AVANT LE DÉBRANCHEMENT. DES ERREURS DE CÂBLAGE PEUVENT ENTRAÎUN FONCTIONNEMENT INADEQUATE ET DANGEREUX.) The proper location of wire connections is shown in the following figure. Figure 14 – Stowe 8323 Wiring Diagram...

  • Page 19: Gas Supply & Connections

    Do NOT bend D'INSTALLATION CAN/CGA-B149 tubing at gas valve connection point after NFPA Code and Hearthstone require the use of compression fitting has been tightened. This a dedicated sediment trap just upstream of the can result in gas leakage at the connection.

  • Page 20: Gas Connections

    Hearthstone Quality Home Heating Products, Inc. Stowe 3 Model 8323  Do NOT remove screws from the gas valve. Do NOT adjust and/or alter any components marked with tamper indicating paint. Motor knob is not to be removed.  Turn off gas supply at the appliance service valve before starting installation, and perform a Gas Leak Test after the installation is complete.

  • Page 21: Pre-Ignition Checks

    Hearthstone Quality Home Heating Products, Inc. Stowe 3 Model 8323 the small flame button on the hand set until you Pre-Ignition Checks hear two (2) short beeps confirming the code is set. WIRING CONNECTIONS NOTE: This is a one-time setting only, and It is not...

  • Page 22: Leak Check

    Hearthstone Quality Home Heating Products, Inc. Stowe 3 Model 8323 GAS CONTROL KNOB SETTINGS 1. Open the gas supply to the valve. 2. Remove the access panel from the front of the stove and set on a non-marring surface. KNOB...

  • Page 23: Pilot Adjustment

    Hearthstone Quality Home Heating Products, Inc. Stowe 3 Model 8323 approved leak test solution to all tubing and pipe connections (including adapters) and the valve inlet and outlet. Bubbles indicate a leak. 6. If leak detected, tighten pipe connections (including adapters) according to "GAS CONNECTIONS"...

  • Page 24: Minimum Flow Adjustment

    Hearthstone Quality Home Heating Products, Inc. Stowe 3 Model 8323 clockwise. Check all connections/pressure tap(s) 2. Carefully and without turning the adjusting for leaks. screw, grasp the plastic conversion plug at 6. If the desired outlet pressure or flow cannot be...
  • Page 25 Hearthstone Quality Home Heating Products, Inc. Stowe 3 Model 8323 7. Using a 4mm (5/32”) allen wrench, loosen and remove the existing low pressure NG screw by turning counter-clockwise until it spins freely. It may be necessary to grasp the screw head with your fingernails or...
  • Page 26 Figure 26 – Tighten LP Low Flow Orifice To Switch the Pilot to LP Operation: Refer to Figures 27-30 The pilot assembly in the Stowe 8323 is a slide convertible unit, only requiring access from the firebox and a 7/16” open-end wrench. To convert Figure 27 –...

  • Page 27: Firebox/Log Set Placement

    Hearthstone Quality Home Heating Products, Inc. Stowe 3 Model 8323 TO SHUT DOWN THE APPLAINCE AND TURN OFF GAS Manual Mode: 1. Remove valve access panel. 2. Turn the Main Valve Knob clockwise to OFF. 3. Turn the ON/OFF switch on the valve to OFF.

  • Page 28: Installation Of The Log Set

    Hearthstone Quality Home Heating Products, Inc. Stowe 3 Model 8323 does not fit into the firebox exactly as outlined, 3. Place Log 2 into the channel in the burner in contact your dealer for assistance. front of log 1 as shown in Figure 34..

  • Page 29: Installation

    Hearthstone Quality Home Heating Products, Inc. Stowe 3 Model 8323 Air Shutter Gently place Log 5 in the indentation on the burner and rest it on log 3 as shown in Figure 37. The air shutter is used to regulate the air-to-gas combustion mixture, which in turn influences the size and color of the flames.

  • Page 30: Restrictor

    Hearthstone Quality Home Heating Products, Inc. Stowe 3 Model 8323 2. The flame should not rise off the pan burner; this is called “lifting”. 3. Flames should not impinge heavily on the log set. They should “fit” through the pre-formed spaces designed in the log set.

  • Page 31: Maxitrol Gv60 Control System Features

    Hearthstone Quality Home Heating Products, Inc. Stowe 3 Model 8323 CE: Suitable for use with gases of EN 437 gas family 1, 2 and 3. APPROVALS CSA: ANSI Z21.78/CSA 6.20 for U.S. & Canada, ANSI Z21.20/CSA 6.20 for U.S. & Canada...

  • Page 32: Manual Operation

    Hearthstone Quality Home Heating Products, Inc. Stowe 3 Model 8323 batteries in the receiver for automatic backup in AMBIENT TEMPERATURE RANGE case of power outage.  Without using a mains adapter, battery Combination control: 32 F to 176 F (0...

  • Page 33: Remote Control Operation (Optional)

    Hearthstone Quality Home Heating Products, Inc. Stowe 3 Model 8323 attempts, STOP ALL ATTEMPTS TO LIGHT PILOT CALL AUTHORIZED SERVICE TECHNICIAN. 8. Once the pilot flame has been established, turn the Manual Knob counter-clockwise to the ON position. Next, turn the Main Valve Knob counter-clockwise.
  • Page 34 Hearthstone Quality Home Heating Products, Inc. Stowe 3 Model 8323 STANDBY MODE (Pilot Flame)  Press and hold small Handset Flame button to decrease • Press and hold small flame to set appliance at flame height or to set pilot flame.
  • Page 35 Hearthstone Quality Home Heating Products, Inc. Stowe 3 Model 8323 LIGHT/DIMMER OPERATION the solenoid valve will be reset to the ON position (NOT APPLICABLE TO HEARTHSTONE STOVES) when the GV60 is switched OFF remotely. • Briefly press SET button to scroll to light bulb icon.
  • Page 36 Hearthstone Quality Home Heating Products, Inc. Stowe 3 Model 8323 MODES OF OPERATION • Briefly pressing the SET button changes the mode of operation in the following order: • Circulating Fan Mode (ONLY for Waitsfield and Stowe models) Turns circulating fan ON and NOTE: Manual mode can also be reached by OFF and adjusts fan speed.
  • Page 37 Hearthstone Quality Home Heating Products, Inc. Stowe 3 Model 8323 SETTING °C/24 HOUR OR °F/12 HOUR CLOCK • Press large flame button • Press OFF and small flame to increase Daytime Set button until display changes from Temperature. Fahrenheit/12 hour clock to Celsius/24 hour clock and vice versa.
  • Page 38 Hearthstone Quality Home Heating Products, Inc. Stowe 3 Model 8323 • Press small flame button • Set the hour by pressing to decrease Nighttime the large flame button. Setback Temperature. • Press OFF or simply wait to complete programming. SETTING PROGRAM TIMERS •...

  • Page 39: Routine Maintenance And Care

    WARNING: DO NOT SUBSTITUTE MATERIALS. For replacement parts, or for information about parts 1. Place ON/OFF switch in 0 (OFF position). or service, contact your local Hearthstone dealer. 2. If gas control is accessible turn main valve knob to the OFF full clockwise position.
  • Page 40 Hearthstone Quality Home Heating Products, Inc. Stowe 3 Model 8323 or enamel when the residue of the cleaners or NOTE: Do not operate the unit for more than polishes is exposed to heat. Excessive buildup of 1-2 minutes without the log set in place.
  • Page 41 Hearthstone Quality Home Heating Products, Inc. Stowe 3 Model 8323 Initializing the Remote Control in place. Pull the glass away from the frame and set it aside. should required synchronize communication between the Receiver and the If replacing gasket only: Remote Control transmitter when you change the batteries in either.

  • Page 42: Parts List

    XX = Finish (e.g. 10 = Matte Black Paint) – Specify finish required when ordering parts WARNING: DO NOT SUBSTITUTE MATERIALS. FOR REPLACEMENT PARTS, OR FOR INFORMATION ABOUT PARTS OR SERVICE, CONTACT YOUR AUTHORIZED HEARTHSTONE RETAILER. For the name of the authorized retailer nearest to you, visit our website www.hearthstonestoves.com...

  • Page 43: Troubleshooting

    Hearthstone Quality Home Heating Products, Inc. Stowe 3 Model 8323 Troubleshooting Symptom Possible Cause Corrective Action 1. Pilot will not light. A. Power supply not plugged in A. Ensure power supply is plugged in and receiving 120V and/or batteries are dead.
  • Page 44 Hearthstone Quality Home Heating Products, Inc. Stowe 3 Model 8323 Symptom Possible Cause Corrective Action 5. Frequent pilot outage. A. Pilot flame may be too low or A. Clean and/or adjust the pilot flame for maximum blowing, (high), causing the pilot impingement on the thermocouple.

  • Page 45: Rating Label

    Hearthstone Quality Home Heating Products, Inc. Stowe 3 Model 8323 Rating Label...

  • Page 46: Warranty

    ) year after the Purchase Date, Hearthstone will pay for warranty labor performed by an authorized Dealer at Hearthstone’s published labor rates in effect at the time the labor is performed only if the appliance is installed by an authorized dealer or their designated representative. Otherwise or thereafter, the Original Purchaser is responsible for the cost of labor.
  • Page 47 Hearthstone or an authorized Dealer, as the case may be. Notwithstanding any other provision of this document, in no event will Hearthstone pay for any Dealer fees or other fees for pick up or delivery of the appliance returned for repair; the Original Purchaser shall be responsible for any such fees.
  • Page 48 Dealer on behalf of Hearthstone, as the case may be, will instruct the Original Purchaser to either return the defective part, or the entire appliance (if requested), to the Dealer or Hearthstone or allow a Dealer to make a service call at the place where the appliance is located. Hearthstone may require that a digital picture be provided to support the claim.

This manual is also suitable for:

8763)Bristol dx

Table of Contents