Section 1: Listing And Code Approvals; Appliance Certifi Cations; Mobile Home Approved; Glass Specifi Cations - Quadra-Fire CASTILEI-MBK Owner's Manual Installation And Operation

Castile Pellet Insert
1
Listing and Code Approvals
A. Appliance Certifi cation
MODEL: Castile Pellet Insert-B
LABORATORY: OMNI Test Laboratories, Inc
REPORT NO. 061-S-77d-6.2
TYPE: Solid Fuel Room Heater/Pellet Fuel
Burning Type Insert
STANDARD: ASTM E1509-2004, ULC S628-93 and
ULC/ORD-C1482-M1990 Room Heater
Pellet Fuel Burning Type and (UM) 84-
HUD, Mobile Home Approved
NOTE: This installation must conform with local codes. In
the absence of local codes you must comply with the ASTM
E1509-2004, ULC S628-93, ULC/ORD-C-1482-M1990,
(UM) 84-HUD
The Castile Pellet Insrt by Quadra-Fire is exempt from Envi-
ronmental Protection Agency certifi cation under 40 CFR
60.531 y defi nition [Wood Heater (A) "Air to Fuel Ratio].
B. Mobile Home Approved
This appliance is approved for mobile home installations
when not installed in a sleeping room and when an outside
combustion air inlet is provided.
The structural integrity of the mobile home fl oor, ceiling, and
walls must be maintained. The appliance must be properly
grounded to the frame of the mobile home and use only listed
pellet vent, Class "L" or "PL" connector pipe.
A Quadra-Fire Outside Air Kit must be installed in a mobile
home installation.
Note: This appliance is also approved for installation
into a shop.
C. Glass Specifi cations
This appliance is equipped with 5mm ceramic glass.
Replace glass only with 5mm ceramic glass. Please contact
your dealer for replacement glass.
D. Electrical Rating
115 VAC, 60 Hz, Start 4.1 Amps, Run 1.1 Amps
NOTE: Some generator or battery back-up systems may
not be compatible with the micro-processor electron-
ics on this appliance. Please consult the power supply
manufacturer for compatible systems.
Page 4
E. BTU & Effi ciency Specifi cations
Particulate
Emissions Rating:
*BTU Output:
Heating Capacity:
Hopper Capacity:
Fuel:
Shipping Weight:
Effi ciency
*BTU output will vary, depending on the brand of fuel you
use in your appliance. Consult your Quadra-Fire dealer for
best results.
These heaters meet the US Environmental Protection
Agency's emissions limits for pellet heaters. Under specifi c
conditions the PS35 stove has been shown to deliver heat
at rates ranging from 8,500 to 28,200 BTU/hr.
WARNING! Risk of Fire! Hearth & Home Technologies dis-
claims any responsibility for, and the warranty and agency
listing will be voided by the below actions.
DO NOT:
• Install or operate damaged appliance
• Modify appliance
• Install other than as instructed by Hearth & Home
Technologies
• Operate the appliance without fully assembling all
components
• Overfi re
• Install any component not approved by Hearth &
Home Technologies
• Install parts or components not Listed or approved.
• Disable safety switches
Improper installation, adjustment, alteration, service or
maintenance can cause injury or property damage.
For assistance or additional information, consult a qualifi ed
installer, service agency or your dealer.
NOTE: Hearth & Home Technologies, manufacturer of
this appliance, reserves the right to alter its products,
their specifi cations and/or price without notice.
Quadra-Fire is a registered trademark of Hearth & Home
Technologies.
7022-122D
1.8 grams/hr
8,500 - 28,200 / hr
up to 1,500 sq. ft. depending on
climate zone
45 lbs
Wood Pellets or Shelled Corn
214 lbs
78%
May 12, 2014