Community Distributed Design D4LP Installation And Operation Maintenance Owner's Manual page 4

Figure 1. Full Ceiling Loudspeaker assembly package contents (typical) . . . . . . . . . . . . 8
Figure 2. Face Only package contents (typical) . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Figure 3. Back Can package contents (typical) . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Figure 4. Optional Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Figure 5. D45-BC Back Can Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Figure 6. D4-FO Loudspeaker Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Figure 7. D4LP-BC Back Can Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Figure 8. D5-FO Loudspeaker Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Figure 9. D6-BC Back Can Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Figure 10. D6-FO Loudspeaker Dimen
Figure 11. D8-BC Back Can Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Figure 12. D8-FO Loudspeaker Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Figure 13. D10-BC Back Can Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Figure 14. D10-FO Loudspeaker Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Figure 15. D10SUB-FO Loudspeaker Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Figure 16. Face Adapter Ring Detail . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Figure 17. Can Adapter/Trim Ring Detail . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Figure 18. Component Part Identification (1) . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Figure 19. Component Part Identification (2) . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
Figure 20. Non-Conduit Guided Wiring to Can and Wire Restraint . . . . . . . . . . . . . . . 20
Figure 21. Internal Wiring Between Can Terminal Block and Loudspeaker . . . . . . . . . 21
Figure 22. Conduit for Protected Wiring to Can . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
Figure 23. Redeploying the plug for wires
entering from conduit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
Figure 24. Cutout template dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
Figure 25. Installing a C-Ring Support Plate onto Tile Bridge Support Rails . . . . . . . . . 23
Figure 26. Drop-Stop tabs (highlighted) snap out over C-Ring Support . . . . . . . . . . . . 24
Figure 27. Turning the can clamp actuators clockwise securely locks the
back can into the ceiling. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
Figure 28. New installation in an existing drywall ceiling. . . . . . . . . . . . . . . . . . . . . 25
Figure 29. New Construction Bracket for Drywall or Lath-and-Plaster Installations . . . 25
Figure 30. Initial position (left) and loudspeaker face twisted to lock (right) . . . . . . . . 28
Figure 31. Four Twist-Assist™ Face tabs inside the Back Can instantly secure
the Loudspeaker to the Back Can with a twist. . . . . . . . . . . . . . . . . . . . . 28
Figure 32. Use the four included, captive, 4mm sheet metal screws to secure
the loudspeaker into the can.. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Figure 33. Grille safety clip and line (left) should look like this (right) when attached. . 29
Figure 34. Setting Loudspeaker Tap . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Community Distributed Design Series
Table of Figures
sions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Installation and Operation Manual Page 4