HearthStone Sterling-Ht 8532 Owner's Manual & Installation Manual

HearthStone Sterling-Ht 8532 Owner's Manual & Installation Manual

Gas-fired direct vent heater

Advertisement

WARNING: If the information in these instructions
is not followed exactly, a fire, or explosion may
result causing property damage, personal injury, or
loss of life.
Do not store, or use gasoline, or other
flammable vapors and liquids near this or any
other gas appliance!
WHAT TO DO IF YOU SMELL GAS:
Do not try to light any appliance.
Do not touch electrical switches; do not use the
phone in your building.
Immediately call your gas supplier from a
neighbor's phone. Follow your gas supplier's
instructions.
If you cannot reach your gas supplier, call the fire
department.
A qualified installer, service agency, or gas supplier
must perform installation and service.
Commonwealth of Massachusetts, all installation of
gas lines and gas fitting shall only be done by a
licensed gas fitter or licensed plumber.
Sterling-Ht
GAS-FIRED DIRECT VENT HEATER
Operate and Maintain This Gas Heater
According To This Instruction Manual
Read This Manual in Its Entirety
AVERTISSEMENT: Assurez-vous de bien suivre les
instructions donné dans cette notice pour réduire
au minimum le risque d'incendie ou pour éviter tout
dommage matéeriel, toute blessure ou la mort.
Ne pas entresposer ni utiliser d'essence ni d'autre
vaperurs
ou
voisinage de cet apprareil ou de tout autre appareil!
QUE FAIRE SI VOUS SENTEZ UNE ODEUR
DE GAZ:
Ne pas tenter d'allumer d'appareil.
Ne touchez à aucun interrupteur. Ne pas vous
servir des téléphones se trouvant dans le
batiment où vous vous trouvez.
Appelez immédiatement votre fournisseur de
gaz depuis un voisin. Suivez les instructions
du fournisseur.
Si vous ne pouvez rejoindre le fournisseur de
gaz, appelez le service dos incendies.
In the
L'installation et service doit être exécuté par un
qualifié
installer,
fournisseur de gaz.
(Model 8532)
Owner's Manual
& Installation Guide
liquides
inflammables
agence
de
service
Sterling Ht Model 8532
Manual: 6400-40428
Revised: 5/31/11
dans
le
ou
le

Advertisement

Table of Contents
loading

Summary of Contents for HearthStone Sterling-Ht 8532

  • Page 1 Sterling-Ht (Model 8532) GAS-FIRED DIRECT VENT HEATER Owner’s Manual & Installation Guide Operate and Maintain This Gas Heater According To This Instruction Manual Read This Manual in Its Entirety WARNING: If the information in these instructions AVERTISSEMENT: Assurez-vous de bien suivre les is not followed exactly, a fire, or explosion may instructions donné...
  • Page 2: Service Record

    Hearthstone Quality Home Heating Products, Inc STERLING-Ht Model 8532 INFORMATION SHEET Use this pag e to record al l relevant information con cerning the purchase, installation, and maintenance of your STERLING Ht Model 8532 Gas-Fired Direct Vent Heater. This information will facilitate servicing, purchase o f replacement parts, and warranty claims (if nece ssary).
  • Page 3: Table Of Contents

    Hearthstone Quality Home Heating Products, Inc STERLING-Ht Model 8532 ABLE OF ONTENTS ELCOME ..........2 ELCOME Congratulations on your purchase of Hearthstone’s Sterling Ht Gas-Fired Direct Vent heater. The ’ ......4 WNER NFORMATION Sterling incorporates the latest in balanced vent gas .........4...
  • Page 4 Hearthstone Quality Home Heating Products, Inc STERLING-Ht Model 8532 ERVICE AUTION Any shield, door, or other component removed for WARNING: do not operate the appliance servicing must be replaced prior to o perating. Any with the fr ont glass removed, cracked, or components of the stove rem oved for servicing m ust broken.
  • Page 5: Wner ' S Information

    Remote thermostats, or wall switches are the floor because some gases (LPG) are heavier available for purchase fr om your local Hearthstone than air and will settle on the floor. If you smell dealer. Once the therm ostat is installed and properly gas immediately follow the What To Do If You adjusted, the desired room temperature is maintained.
  • Page 6: Nstaller Nformation

    Hearthstone Quality Home Heating Products, Inc STERLING-Ht Model 8532 ’ installing the unit. If any damage, or a missing part, is NSTALLER NFORMATION detected, immediately contact y our dealer. Do not install or put into service a damaged or incomplete Codes heater.
  • Page 7: Combustibles

    Hearthstone Quality Home Heating Products, Inc STERLING-Ht Model 8532 ! Do not oper ate the stove with  ARNING the glass front remov ed, cracked, or broken. TEMS EQUIRED FOR NSTALLATION * External regulator (for propane/L.P.G. only) * Piping which complies with all codes * Pipe sealant approved for use with propane/L.P.G.
  • Page 8: Specifications

    Hearthstone Quality Home Heating Products, Inc STERLING-Ht Model 8532 18" (458mm) 2" (51mm) 2" (51mm) 4" (102mm) Parallel Installations 1" (26mm) 14" (355mm) 3" (76mm) 3" (76mm) 2" (51mm) Floor Corner Installations Mantel Installations LEARANCE TO OMBUSTIBLES SPECIFICATIONS: ISTED IRECT...
  • Page 9 Hearthstone Quality Home Heating Products, Inc STERLING-Ht Model 8532...
  • Page 10: Venting Information

    Hearthstone Quality Home Heating Products, Inc STERLING-Ht Model 8532 Vertical Vent Cap ENTING NFORMATION Snorkel 36” Vinyl Siding Standoff 4 x 6 5/8” The Sterling is approved for installation only Round Ceiling Support Wall with the following venting manuafcturers Thimble Covers products.
  • Page 11 Hearthstone Quality Home Heating Products, Inc STERLING-Ht Model 8532 A. Fireplace & Existing Chimney Installation The use of an existing chimney as an air intake is not covered under the ANSI Z21.88-1998•CSA 2.33-M98 test methods and the resulting ITS/WHI product certification. The Code Authority Having Jurisdiction must...
  • Page 12 Hearthstone Quality Home Heating Products, Inc STERLING-Ht Model 8532 Horizontal Terminations for 5"x 8" Pipe.
  • Page 13 Hearthstone Quality Home Heating Products, Inc STERLING-Ht Model 8532 Horizontal Terminations for 4"x 6" Pipe (Requires the use of Top Exit Kit, # 95-60320) Note: All top exit configurations require a minimum of a 24” section of pipe directly off the unit...
  • Page 14 Hearthstone Quality Home Heating Products, Inc STERLING-Ht Model 8532 Vertical Terminations - Straight or (2) 45 Elbows (4"x 6” Pipe Only)
  • Page 15 Hearthstone Quality Home Heating Products, Inc STERLING-Ht Model 8532 Vertical Terminations - (1) or (2) 90 Elbows (4"x 6" Pipe)
  • Page 16: Attaching Your Venting

    Hearthstone Quality Home Heating Products, Inc STERLING-Ht Model 8532 Loosen the Phillips head screw and rotate th TTACHING ENTING locator, found on the rear middle of the stove to position which corresponds to the ap propriate Follow the instructions in either of the 5”x8”...
  • Page 17: As Onnections

    STERLING Ht Gas-Fired Direct Vent heater HearthStone Quality Home Heating Products Inc Conditionally approved for purchased mobile home Cet appareil peut être installé dans un maison installation. This appliance may be installed in an préfabriquée (mobile) déjà installée à d emeure si les aftermarket permanently located, manufactured règlements locaux le permettent.
  • Page 18: Log Placement

    Do not use any other type of fiber logs, wood logs, or the ember burner. On the underside of the log other materials in the firebox. If the original log set there is an “ L-shaped” cutout that lines up the is damaged, or broken , contact yo ur Hearthstone...
  • Page 19: Emoval Of The Og Et

    STERLING Ht Gas-Fired Direct Vent heater HearthStone Quality Home Heating Products Inc log on the ember burner, in t he appropriate EMOVAL OF THE position. It should sit as shown. Caution Log set retains heat and can be very hot, if previously lit! Allow 1 hour after pilot light is turne d off before handling.
  • Page 20: Ighting The Nit The Irst

    STERLING Ht Gas-Fired Direct Vent heater HearthStone Quality Home Heating Products Inc to be lit for the first time. Each unit is tested prior to IGHTING THE NIT THE shipment by the manufacturer, so ignition should take place without failure. However, a number of small...
  • Page 21: Turning Off The Unit

    STERLING Ht Gas-Fired Direct Vent heater HearthStone Quality Home Heating Products Inc 7. Turn gas control knob counterclockwise to 2. If shutting the unit off for the non-heating season, “ON”. turn the gas control knob fully clockwise to the 8. Select “ON” or “T-STAT” position on the “OFF”...
  • Page 22: As Onversions

    STERLING Ht Gas-Fired Direct Vent heater HearthStone Quality Home Heating Products Inc to loosen the bolt. Sliding the control levers forward or backward will open and close the shutters. This nut is hot and should not be touched. Use only metal tools for this adjustment.
  • Page 23: Outine Aintenance And

    STERLING Ht Gas-Fired Direct Vent heater HearthStone Quality Home Heating Products Inc fiber logs o ut of the fir ebox, re-install the glass OUTINE AINTENANCE assembly and briefly light the unit according to lighting instructions described on Page 4. Check to ensure a flame is burnin g from each burner port.
  • Page 24 STERLING Ht Gas-Fired Direct Vent heater HearthStone Quality Home Heating Products Inc Wiring Diagram - Sterling-Ht DV 30 c 50 60 70 80 90 HearthStone 50 70 90 Wiring Color KEY: IRING NSTRUCTIONS Caution: Label all wires prior to disconnection when servi cing controls. Wiring errors can cause improper and dangerous operation.
  • Page 25: Arts Lists

    STERLING Ht Gas-Fired Direct Vent heater HearthStone Quality Home Heating Products Inc ARTS ISTS Part No. Description Part No. Description 1541-330 STONE: TOP SIDE 5532-075 LOW FLAME KNOB, EXTENSION ROD 1541-340 STONE: TOP, CENTER 5532-077 HIGH FLAME KNOB, EXTENSION ROD 1546-462A STONE: POL,8"x9-1/2", STG...
  • Page 26 115 VOLTS @ 60Hz, LESS THAN 2.0A EDGE OF SIDE TO: SIDEWALL 4” / 100 mm Several Optional kits are available through HearthStone or your local HearthStone dealer. A blower assembly may be used (kit# 95-57320) , spark screen (kit# 95-69320), top exit(kit# 95-60320), and two different remote controls (kit #90-56912 &...
  • Page 27: Troubleshooting Guide

    TROUBLESHOOTING GUIDE Symptom Possible Cause Corrective Action 1. Pilot will not light. A. Using the piezo sparker, try to light the pilot. If it will not A. Insufficient gas pressure, light, check the inlet gas pressure. air in the pilot line, or dirty or kinked gas line.
  • Page 28 Symptom Possible Cause Corrective Action 3. Pilot burning, no gas to A. Thermostat switch or A. Check thermostat/wiring for proper connections. Place main burner, valve knob in wires defective. jumper wire across terminals at thermostat. If burner the "ON" position, comes on, replace defective thermostat.
  • Page 29 Symptom Possible Cause Corrective Action 8. Floating flames, lazy ill- A. Potentially dangerous A. Check the appliance input rate and reduce if necessary. defined, quiet flames, which incomplete combustion due The air intake/exhaust flow system may be too restrictive roll around, sometimes to incorrect air to fuel ratio or blocked (the rate at which the exhaust leaves [draft] completely off of the port,...
  • Page 30: Warranty Registration

    WARRANTY REGISTRATION The Original Purchaser may send a completed and signed Warranty Registration Form, which is enclosed in the Stove warranty packet, to the following address: Hearthstone Quality Home Heating Products, Inc. Warranty Department 317 Stafford Avenue Morrisville, VT 05661-8695 NOTE: SENDING IN T HE SIGNED WARRANTY REGISTRATION FORM IS NOT A CONDITION OF WARRANTY COVERAGE OR HEARTHSTONE’S PERFORMANCE.

Table of Contents