HearthStone Tucson Owner's Manual & Installation Manual

HearthStone Tucson Owner's Manual & Installation Manual

Gas-fired direct-vent heater
Hide thumbs Also See for Tucson:

Advertisement

Quick Links

Owner's Manual & Installation Guide
Tucson
for the
DIRECT-VENT HEATER
WARNING:
If
the
instructions is not followed exactly, a fire or
explosion may result causing property damage,
personal injury or loss of life.
Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.
WHAT TO DO IF YOU SMELL GAS:
• Do not try to light any appliance.
• Do not touch electrical switches; do not use
the phone in your building.
• Immediately call your gas supplier from a
neighbors phone. Follow your gas suppliers
instructions.
• If you cannot reach your gas supplier, call the
fire department.
A qualified installer, service agency or gas supplier
must perform installation and service.
GAS-FIRED
(8700)
information
in
these
READ THIS OWNER'S
MANUAL
Operate and maintain this gas heater
according to this instruction manual.
Read This Manual In Its Entirety.
AVERTISSEMENT:
suivre les instructions donné dans cette notice
pour réduire au minimum le risque d'incendie
ou pour éviter tout dommage matéeriel, toute
blessure ou la mort.
Ne pas entresposer ni utiliser d'essence ni d'autre
vaperurs
ou
liquides
voisinage
de cet apprareil ou de tout autre appareil.
QUE FAIRE SI VOUS SENTEZ UNE ODEUR
DE GAZ:
• Ne pas tenter d'allumer d'appareil.
• Ne touchez à aucun interrupteur. Ne pas vous
servir des téléphones se trouvant dans le
batiment où vous vous trouvez.
• Appelez immédiatement votre fournisseur de
gaz depuis un voisin. Suivez les instructions
du fournisseur.
• Si vous ne pouvez rejoindre le fournisseur de
gaz, appelez le service dos incendies.
L'installation et service doit être exécuté par un
qualifié
installer,
agence
fournisseur de gaz.
Assurez-vous
de
bien
inflammables
dans
de
service
ou
6400-40432
Model #8700
05-22-03
le
le

Advertisement

Table of Contents
loading

Summary of Contents for HearthStone Tucson

  • Page 1: Read This Owner'smanual

    Owner’s Manual & Installation Guide READ THIS OWNER’S MANUAL Operate and maintain this gas heater according to this instruction manual. Tucson for the GAS-FIRED (8700) Read This Manual In Its Entirety. DIRECT-VENT HEATER WARNING: information these AVERTISSEMENT: Assurez-vous bien instructions is not followed exactly, a fire or suivre les instructions donné...
  • Page 2 Tucson Model #8700 HearthStone Quality Home Heating Products Inc HearthStone Quality Home Heating Products 317 Stafford Avenue, Morrisville, Vermont 05661 E-Mail: Inquiry@HearthStoneStoves.com...
  • Page 3: Service Record

    Phone: Date of Purchase: Installed by: Phone: Date of Installation: Gas Supplier: Phone: Read this Owner’s Manual before installing or operating the TUCSON heater. Retain this manual for future reference. SERVICE RECORD Date Who Performed Work Work Performed Notes: WHAT...
  • Page 4: Introduction

    Kit which turns on and heat for years to come. The combination of off independently of the burner flames. natural stones and cast iron gives the Tucson When the switch, which allows you to turn a pleasing look that can be maintained with the fan on or off and control the speed of the minimum care.
  • Page 5: Table Of Contents

    Tucson Model #8700 HearthStone Quality Home Heating Products Inc ABLE OF ONTENTS The installation must conform to local codes READ THIS OWNER’S MANUAL..1 or, in the absences of local codes, the current National Fuel Gas Code, ANSI Z223.1 (NFPA ...........
  • Page 6: Fire

    This gas heater is designed to burn natural gas or liquid propane (LP). Never burn any ERVICE AUTION fuel not intended for use with this unit. If you believe your Tucson is not, in any way, performing properly, immediately ARNING...
  • Page 7: Ceramic Fiber Log Safety Information

    URNERS If the decorative ceramic log material The standing pilot light equipped on this gas supplied with the Tucson is damaged or heater is lit by using a piezoelectric spark missing, it must be replaced with the same, generator as described elsewhere in this approved replacement parts supplied by the manual.
  • Page 8 (mobile) home, where not replaced prior to operating. If you believe prohibited by local codes. your Tucson is not performing properly in what ever, immediately This appliance is only for use with the discontinue operation until the unit has been type(s) of gas indicated on the rating plate.
  • Page 9: Specifications

    SPECIFICATIONS: ISTED IRECT EATER Listed: Gas-Fired Direct-Vent Fireplace Heater Model: Tucson Direct-Vent Gas Fireplace Heater Testing Agency: Intertek Testing Services NA Inc. (ITS) Tested to: ANSI Z21.88-1998, CSA 2.33-M98, CAN/CGA2.17 Certified for Canada Approved for Mobile Home Installation (see page 7)
  • Page 10: Owner ' S Information

    Tucson Model #8700 HearthStone Quality Home Heating Products Inc overall efficiency of the unit as the heat ’ WNER NFORMATION from the pilot is wasted. When putting the The installation must conform with local unit back into service, follow the lighting codes or, in the absences of local codes, the instructions described on page 31.
  • Page 11 Regularly check to insure the area around lighting instructions described on page 31. the Tucson is kept free from combustible Check to insure a flame is burning from materials, gasoline, and other flammable each burner port.
  • Page 12 Authorized HearthStone Dealer. 1. Allow the Tucson to cool completely. Remove the existing gasket by grasping one end and pulling firmly. 2. Use a wire brush or the tip of a screwdriver to clean the channel of remaining gasket.
  • Page 13: Installer

    Tucson Model #8700 HearthStone Quality Home Heating Products Inc ’ NSTALLER NFORMATION TEMS EQUIRED FOR ODES NSTALLATION Adhere to all local codes or, in their * External regulator (for propane/L.P.G. absence, latest edition only) NATIONAL FUEL GAS CODE ANSI * Piping which complies with local codes Z223.1 (NFPA 54) or CAN/CGA B149...
  • Page 14: Npack And Nspect For

    ROTECTION unpacking and installing the unit. If any The Tucson may be placed on a non- damage or missing parts are detected, combustible surface or wood floor. immediately contact your dealer. Do not...
  • Page 15 Tucson Model #8700 HearthStone Quality Home Heating Products Inc LEARANCE TO OMBUSTIBLES Due to high surface temperatures, the unit should be located out of traffic and away from furniture and draperies. Clothing and other flammable material should not be placed on or near the heater. When...
  • Page 16 Tucson Model #8700 HearthStone Quality Home Heating Products Inc Figure 7: Snorkel-Wall Clearance To Combustibles Figure 6: Snorkel-Mantle Clearance To Combustibles...
  • Page 17 Tucson Model #8700 HearthStone Quality Home Heating Products Inc Acceptable Direct-Vent TERMINATION Cap locations. Figure 8...
  • Page 18: Venting Information

    Tucson Model #8700 HearthStone Quality Home Heating Products Inc ENTING NFORMATION ENTING ONNECTION The Tucson Direct-Vent is approved for installation only with vent connecting components listed on this page. Use the following instructions along with pipe manufacturer’s instructions to complete the installation.
  • Page 19 Tucson Model #8700 HearthStone Quality Home Heating Products Inc (refer to Figure 11 for proper adjustment ESTRICTION LATE plate i n dex location) ‘A’ in Figure 11 shows The restriction plate is used to control the the locating screw that determines the draft of the heater.
  • Page 20 Direct, Secure Vent ONFIGURATION components acceptable installation, The Tucson cannot be vented jointly with along with minimum venting any other solid fuel or gas appliance. It must available. The venting system must be be vented directly to the outside of the...
  • Page 21 Tucson Model #8700 HearthStone Quality Home Heating Products Inc Top of Outlet opening 14" snorkel wall thimble wall thimble cover 9"straight 45 degree elbow Top of inner stove exit Figure 12: Components For a Typical Snorkel Installation TOP OF 990B...
  • Page 22 Tucson Model #8700 HearthStone Quality Home Heating Products Inc PPROVED ERTICAL ERMINATION ENTING ONFIGURATIONS WITH (2) 45 LBOWS OR FFSETS (2) 90 IGURE LBOWS IGURE • 10' minimum system height (with or without offsets) • 35' maximum system height • 6' maximum offset (refer to Figure 14) •...
  • Page 23 Tucson Model #8700 HearthStone Quality Home Heating Products Inc PPROVED ENTING ONFIGURATION FOR ORIZONTAL ERMINATION (1) 90 LBOW • The termination must fall within the area outlined by the shaded area shown in the illustration below. • A minimum of 9" rise is required directly off the heater.
  • Page 24 Tucson Model #8700 HearthStone Quality Home Heating Products Inc PPROVED ONFIGURATION IREPLACE NSTALLATION • The termination must fall within the demarcation line shown in illustration. Use the indicated restriction plate position. Restriction plate # 5950-922. Figure 17: Co-Linear & Chimney as Air Inlet...
  • Page 25 Tucson Model #8700 HearthStone Quality Home Heating Products Inc NSTALLATION NSTRUCTIONS FOR THE TANDARD ORIZONTAL ERMINATION INIMUM #97-65001) ENTING › 1. Install the 4” inner collar by first Caution: For building with vinyl siding, placing the 4” x 6” gasket ring onto...
  • Page 26: Electrical Connections

    IRING controlled by a 750 millivolt DC two-wire circuit. The thermostat should be connected to the Tucson using no more than 40’ (12 m) of the provided insulated thermostat wire. The EMOTE ONTROL thermostat wire from the Tucson to the...
  • Page 27 Tucson Model #8700 HearthStone Quality Home Heating Products Inc IRING NSTRUCTIONS CAUTION: Label all wires prior to disconnection when servicing controls. Wiring errors › can cause improper and dangerous operation. Verify proper operation after servicing. (Attention: Au moment de l’entretien des commandes, étiquetez tous les fils avant le débranchement.
  • Page 28: Gas Supply & Connections

    ½ psig. The Tucson must be National Fuel Gas Code ANSI Z223.1 isolated from the gas supply piping system...
  • Page 29: Log Placement

    Tucson Model #8700 HearthStone Quality Home Heating Products Inc Once connected to the gas supply, the firebox turning supply line and manifold gas pressures must counterclockwise. Be careful not to be tested. The supply line pressure is tested, chip the enamel when loosening the to insure it meets the minimum gas supply bolt.
  • Page 30 Tucson Model #8700 HearthStone Quality Home Heating Products Inc Figure 21 Log Set EMOVAL OF CAUTION: The log set and charcoal embers retain heat and can be very hot! Allow 2 to 3 hours after pilot light is turned off before handling.
  • Page 31: Lighting The Unit For The ................................................................... 31 Initial Adjustments

    MOKE AND UMES ARNING When lit for the first time, the Tucson will emit some smoke and fumes. This is normal “off-gassing” of the paints and oils used in the manufacturing and assembly of the unit. Open windows...
  • Page 32 NITIAL DJUSTMENTS supply line pressure, restriction plate Once the Tucson has been set in place, position, altitude, gas type conversions, and connected and assembled as described in the other variables. Clearances Combustibles, Venting...
  • Page 33 TUCSON Gas-Fired Direct-Vent HearthStone Quality Home Heating Products Inc To determine if the air shutter needs 4. Push in and turn gas control knob adjustment, it is necessary to view the flame clockwise to “OFF”. (If not previously pattern with the variable output control knob lit, the knob should be in this position.)
  • Page 34 TUCSON Gas-Fired Direct-Vent HearthStone Quality Home Heating Products Inc 10. Shut the gas control valve access door. PPLIANCE 11. Plug in the fan accessory, if so equipped. 1. Set the thermostat to the “OFF” 12. If T’stat was selected, set thermostat to position or turn the ON/OFF/T- “ON”...
  • Page 35 The flame on pattern is correct: the pilot should look like Figure 23. Controlling the Tucson by the wall-mounted 1. The flame should not be dirty, smoky, thermostat may become erratic, nonexistent, sooty, or lick the top of the stove.
  • Page 36: Maintenance And Care

    To clean the firebox, set the Regularly check to insure the area around thermostat to the “OFF” position and turn the Tucson is kept free and clear from off the gas at the gas control valve. When combustible materials, gasoline, and other the unit is cool, remove the front and flammable vapors and liquids.
  • Page 37 TUCSON Gas-Fired Direct-Vent HearthStone Quality Home Heating Products Inc Once a year the unit and its venting glass cleaner or a window cleaning fluid will system should be inspected by a qualified work adequately. Do not clean when hot! service technician to ensure that it is ›...
  • Page 38 ARNING Do not substitute Materials. For replacement parts, or for information about parts or service, contact your authorized HearthStone retailer. For the name of the authorized retailer nearest to you, call (802) 888-5235 or write: HearthStone Quality Home Heating Products 317 Stafford Ave.
  • Page 39: Troubleshooting

    TUCSON Gas-Fired Direct-Vent HearthStone Quality Home Heating Products Inc TROUBLESHOOTING Symptom Possible Cause Corrective Action 1. Pilot will not A. Insufficient gas pressure, A. Using the piezo sparker, try to light the light. air in the pilot line, or dirty or pilot.
  • Page 40 TUCSON Gas-Fired Direct-Vent HearthStone Quality Home Heating Products Inc TROUBLESHOOTING Symptom Possible Cause Corrective Action 3. Pilot burning, no A. Thermostat switch or A. Check thermostat/wiring for proper gas to main burner, wires defective. connections. Place jumper wire across valve knob in the terminals at thermostat.
  • Page 41 TUCSON Gas-Fired Direct-Vent HearthStone Quality Home Heating Products Inc TROUBLESHOOTING Symptom Possible Cause Corrective Action 8. Floating flames, A. Potentially dangerous A. Check the appliance input rate and reduce lazy ill-defined, incomplete combustion due if necessary. The air intake/exhaust flow...
  • Page 42 All obligations of HearthStone under this document commence on the date the Original Purchaser purchases the Stove (the “Purchase Date”). LIMITED LIFETIME WARRANTY HearthStone warrants the following parts of the Stove against the following occurrences that result from defects in material and workmanship: •...
  • Page 43 A defect in any part of the Stove if the Original Purchaser fails to comply with HearthStone’s or a Dealer’s request to ship the part or the Stove to HearthStone or a Dealer, as the case may be. THE WARRANTIES CONTAINED IN THIS DOCUMENT ARE EXCLUSIVE AND ARE GIVEN BY...
  • Page 44: Warranty Registration

    HearthStone or the Dealer, as the case may be, will instruct the Original Purchaser to either return the defective part, or the entire Stove (if needed), with shipping prepaid, to HearthStone or a Dealer or allow a Dealer to make a service call at the place where the Stove is located.

This manual is also suitable for:

Tucson 8700

Table of Contents