HearthStone Tucson 8700 Owner's Manual & Installation Manual

HearthStone Tucson 8700 Owner's Manual & Installation Manual

Gas-fired b-vent heater
Hide thumbs Also See for Tucson 8700:

Advertisement

Owner's Manual & Installation Guide
Tucson
for the
B-VENT HEATER
WARNING:
If
the
instructions is not followed exactly, a fire or
explosion may result causing property d amage,
personal injury or loss of life.
Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.
WHAT TO DO IF YOU SMELL GAS:
• Do not try to light any appliance.
• Do not touch electrical switches; do not use
the phone in your building.
• Immediately call your gas supplier from a
neighbors phone. Follow your gas suppliers
instructions.
• If you cannot reach your gas supplier, call the
fire department.
A qualified installer, service agency or gas supplier
must perform installation and service.
GAS-FIRED
(8720)
information
in
these
READ THIS OWNER'S
MANUAL
Operate and maintain this gas heater
according to this instruction manual.
Read This Manual In Its Entirety.
AVERTISSEMENT:
suivre les instructions donné dans cette notice
pour réduire au minimum le risque d'incendie
ou pour éviter tout dommage matéeriel, toute
blessure ou la mort.
Ne pas entresposer ni utiliser d'essence ni d'autre
vaperurs
ou
liquides
voisinage
de cet apprareil ou de tout autre appareil.
QUE FAIRE SI VOUS SENTEZ UNE ODEUR
DE GAZ:
• Ne pas tenter d'allumer d'appareil.
• Ne touchez à aucun interrupteur. Ne pas vous
servir des téléphones se trouvant dans le
batiment où vous vous trouvez.
• Appelez immédiatement votre fournisseur de
gaz depuis un voisin. Suivez les instructions
du fournisseur.
• Si vous ne pouvez rejoindre le fournisseur de
gaz, appelez le service dos incendies.
L'installation et service doit être exécuté par un
qualifié
installer,
agence
fournisseur de gaz.
Assurez-vous
de
bien
inflammables
dans
de
service
ou
Model #8720
6400-40433
11-24-04
le
le

Advertisement

Table of Contents
loading

Summary of Contents for HearthStone Tucson 8700

  • Page 1 Owner’s Manual & Installation Guide READ THIS OWNER’S MANUAL Operate and maintain this gas heater Tucson according to this instruction manual. for the GAS-FIRED (8720) Read This Manual In Its Entirety. B-VENT HEATER WARNING: information these AVERTISSEMENT: Assurez-vous bien instructions is not followed exactly, a fire or suivre les instructions donné...
  • Page 2: Service Record

    Tucson Model #8700 HearthStone Quality Home Heating Products Inc INFORMATION SHEET Record, on this page, all relevant information concerning the purchase, installation, and maintenance of your TUCSON Gas-Fired B-Vent heater. This information will facilitate servicing, purchase of replacement parts, and warranty claims (if necessary). Keep your original receipt in a safe place as proof of purchase.
  • Page 3: Read This Owner's Manual

    ERSONNEL Verify the gas connections and venting A wall-mounted thermostat is provided by systems with requirements of local, regional HearthStone. Regardless of how you set the or national installation codes. Qualified variable output control, when the optional service personnel must inspect the gas heater...
  • Page 4: Table Of Contents

    Tucson Model #8700 HearthStone Quality Home Heating Products Inc smoke/odor. If the logs appear to smoke, turn ABLE OF ONTENTS the heater off and call a qualified service READ THIS OWNER’S MANUAL..1 technician. The appliance and its individual shutoff valve ...........
  • Page 5: Safety Information

    Tucson Model #8700 HearthStone Quality Home Heating Products Inc the valve control knob clockwise to “OFF”. supervised when in the same room as the The unit should be cool prior to servicing appliance. Clothing or other flammable and cleaning. Any safety screen, guard, or...
  • Page 6 Tucson Model #8700 HearthStone Quality Home Heating Products Inc grounding prong from the plug or otherwise attempt circumvent grounding protection provided with the unit. IGHT ILOT OR URNERS The standing pilot light equipped on this gas heater is lit by using a piezoelectric spark generator as described elsewhere in this manual.
  • Page 7 Use of components supplied (Cet appareil peut être installé dans un HearthStone on the stove or vent system maison préfabriquée (mobile) déjá installée voids all warranties. Do not substitute á demeure si les réglements locaux le components.
  • Page 8: Specifications

    Tucson Model #8700 HearthStone Quality Home Heating Products Inc SPECIFICATIONS: : B-V ISTED EATER Listed: Gas-Fired B-Vent Fireplace Heater Model: Tucson B-Vent Gas Fireplace Heater Testing Agency: Intertek Testing Services NA Inc. (ITS) Tested to: ANSI Z21.88-2002, CSA 2.33-M02, CAN/CGA2.17-M91...
  • Page 9: Owner ' S Information

    Tucson Model #8700 HearthStone Quality Home Heating Products Inc ’ WNER NFORMATION OUTINE AINTENANCE AILY PERATION Tucson requires minimal routine Tucson gas-fired heater easily maintenance and care. The unit should operated by the homeowner once installed always be cool and off when being cleaned.
  • Page 10 Tucson Model #8700 HearthStone Quality Home Heating Products Inc , & B IREBOX ILOT URNER PILOT PILOT CLIP FLAME UBES The firebox should receive periodic cleaning to prevent the accumulation of dust, lint, and THERMOCOUPLE THERMOPILE PILOT IGNITER other debris. To clean the firebox, set the thermostat to the “OFF”...
  • Page 11 Tucson Model #8700 HearthStone Quality Home Heating Products Inc the gasket ends meet before trimming any excess. Do not overlap the gasket ends or leave ends with ragged edges. 7. Firmly and evenly press the gasket to seat it in its channel.
  • Page 12: Information

    Tucson Model #8700 HearthStone Quality Home Heating Products Inc ’ NSTALLER NFORMATION TEMS EQUIRED FOR ODES NSTALLATION Adhere to all local codes or, in their * External regulator (for propane/L.P.G. absence, latest edition only) NATIONAL FUEL GAS CODE ANSI * Piping which complies with local codes Z223.1 (NFPA 54) or CAN/CGA B149...
  • Page 13: Npack And Nspect For

    Tucson Model #8700 HearthStone Quality Home Heating Products Inc the logs aside until called for during the NPACKING AND NSPECTION installation. NPACK AND NSPECT FOR AMAGE The Tucson is packaged by the manufacturer To install the stones, use the instructions that are...
  • Page 14 Tucson Model #8700 HearthStone Quality Home Heating Products Inc LEARANCE TO OMBUSTIBLES Due to high surface temperatures, the unit 2.00 14-1/2" should be located out of traffic and away from furniture and draperies. Clothing and 10-1/4" other flammable material should not be placed on or near the heater.
  • Page 15 Tucson Model #8700 HearthStone Quality Home Heating Products Inc Figure 6: Mantle Clearance To Combustibles Figure 7: Wall Clearance To Combustibles vent pipe may be used within the same room Venting as the Tucson so long as adequate (6" or 152...
  • Page 16 Tucson Model #8700 HearthStone Quality Home Heating Products Inc confirm that the vent is unobstructed. The an outside air source; the unit must take its vent can not be connected with a flue combustion air from the living space in serving a solid fuel appliance.
  • Page 17 Tucson Model #8700 HearthStone Quality Home Heating Products Inc The Tucson operates in a normal fashion, thermostat and neither will operate if there is satisfied by the simulated draft. A series of a power failure. For installations requiring interlocking safety...
  • Page 18: Electrical Connections

    Tucson Model #8700 HearthStone Quality Home Heating Products Inc LECTRICAL ONNECTIONS NOTE: OPEN VALVE DOOR UNDER THE ASH LIP FOR ELECTRICAL AND GAS CONNECTIONS. central heating system, or a nearby drafty HERMOSTAT window. The ON/OFF/T’stat switch or wall mounted Placement of the thermostat on an inside...
  • Page 19 Tucson Model #8700 HearthStone Quality Home Heating Products Inc IRING NSTRUCTIONS CAUTION: Label all wires prior to disconnection when servicing controls. Wiring errors › can cause improper and dangerous operation. Verify proper operation after servicing. (Attention: Au moment de l’entretien des commandes, étiquetez tous les fils avant le débranchement.
  • Page 20: Gas Supply & Connections

    Tucson Model #8700 HearthStone Quality Home Heating Products Inc NOTE: If an optional blower is to be installed now or in the future, make sure the gas line is installed as close to the floor as possible. Figure 9: Gas Control Valve maximum demand of the unit without undue &...
  • Page 21: Log Placement

    Tucson Model #8700 HearthStone Quality Home Heating Products Inc Once connected to the gas supply, the levels of carbon monoxide. If the log set supply line and manifold gas pressures must does not set into the firebox exactly as be tested. The supply line pressure is tested, outlined, contact your dealer for assistance.
  • Page 22 Tucson Model #8700 HearthStone Quality Home Heating Products Inc Figure ll Log Set...
  • Page 23 TUCSON Gas-Fired Direct-Vent HearthStone Quality Home Heating Products Inc the manufacturing and assembly of the unit. Open windows vent the room if EMOVAL OF necessary. The off gassing and fumes will subside after the first 10 to 20 minutes of CAUTION: The log set and charcoal embers operation.
  • Page 24: Initial Adjustments

    TUCSON Gas-Fired Direct-Vent HearthStone Quality Home Heating Products Inc spark at the pilot light assembly. Do not without failure. However, a number of small attempt to light the unit with a match or by adjustments necessary any means than the piezoelectric spark.
  • Page 25 TUCSON Gas-Fired Direct-Vent HearthStone Quality Home Heating Products Inc immediately follow the What To Do If You Smell Gas! warning on the cover of When pressing/clicking NOTE this Manual. If you do not smell gas, piezoelectric spark ignition button to light proceed to the next step.
  • Page 26 TUCSON Gas-Fired Direct-Vent HearthStone Quality Home Heating Products Inc the “OFF” position. Do not force Allow the unit to operate for 10 minutes the knob to turn. enabling the entire unit to reach temperature and for the flame pattern to stabilize. The...
  • Page 27 TUCSON Gas-Fired Direct-Vent HearthStone Quality Home Heating Products Inc Note: Very little movement is needed to result incomplete combustion, substantially change the burn and flame efficiency and a dirty burn. There are two patterns. simple guidelines to aid in determining the...
  • Page 28: Parts Lists

    ARNING Do not substitute Materials. For replacement parts, or for information about parts or service, contact your authorized HearthStone retailer. For the name of the authorized retailer nearest to you, call (802) 888-5232 or write: HearthStone Quality Home Heating Products 317 Stafford Ave.
  • Page 29: Troubleshooting

    TUCSON Gas-Fired Direct-Vent HearthStone Quality Home Heating Products Inc TROUBLESHOOTING Symptom Possible Cause Corrective Action 1. Pilot will not A. Insufficient gas pressure, A. Using the piezo sparker, try to light the light. air in the pilot line, or dirty or pilot.
  • Page 30 TUCSON Gas-Fired Direct-Vent HearthStone Quality Home Heating Products Inc TROUBLESHOOTING Symptom Possible Cause Corrective Action 3. Pilot burning, no A. Thermostat switch or A. Check thermostat/wiring for proper gas to main burner, wires defective. connections. Place jumper wire across valve knob in the terminals at thermostat.
  • Page 31 TUCSON Gas-Fired Direct-Vent HearthStone Quality Home Heating Products Inc TROUBLESHOOTING Symptom Possible Cause Corrective Action 8. Floating flames, A. Potentially dangerous A. Check the appliance input rate and reduce lazy ill-defined, incomplete combustion due if necessary. The air intake/exhaust flow...
  • Page 32 All obligations of HearthStone under this document commence on the date the Original Purchaser purchases the Stove (the “Purchase Date”). LIMITED LIFETIME WARRANTY HearthStone warrants the following parts of the Stove against the following occurrences that result from defects in material and workmanship: •...
  • Page 33: Damage

    A defect in any part of the Stove if the Original Purchaser fails to comply with HearthStone’s or a Dealer’s request to ship the part or the Stove to HearthStone or a Dealer, as the case may be. THE WARRANTIES CONTAINED IN THIS DOCUMENT ARE EXCLUSIVE AND ARE GIVEN BY...
  • Page 34: Warranty Registration

    HearthStone or the Dealer, as the case may be, will instruct the Original Purchaser to either return the defective part, or the entire Stove (if needed), with shipping prepaid, to HearthStone or a Dealer or allow a Dealer to make a service call at the place where the Stove is located.

Table of Contents