Electrical System Troubleshooting - E-TON VIPER 50 ST Service Manual

12. ELECTRICAL SYSTEM
12.1 TROUBLESHOOTING
12.2 IGNITION COIL
12.3 BATTERY CAUTION
12.4 BATTERY INSPECTION
12.1 TROUBLESHOOTING
ENGINE STARTS BUT STOPS
NO SPARK AT PLUG
ENGINE STARTS BUT RUNS POORLY
CHARGING SYSTEM FAILURE
ENGINE INTERMITTENT POWER
STARTER MOTOR WILL NOT TURN
STARTER MOTOR AND ENGINE TURN,
BUT ENGINE DOES NOT START
REMOTE CONTROLLER INCAPABLE ACTION
TO MAKE ENGINE UNABLE RUNNING
12.5 CHARGING
12.6 ELECTRIC STARTER
12.7 WIRING DIAGRAMS
12.8 SPEEDOMETER AND FUEL METER
12.9 WIRING DIAGRAM
★ IMPROPER IGNITION TIMING
★ FAULTY SPARK PLUG
★ ENGINE STOP SWITCH AT " OFF "
★ FAULTY IGNITION COIL
★ FAULTY GENERATOR
★ FAULTY CDI UNIT
★ POOLY CONNECTED:
Between CDI and ignition coil
Between alternator and CDI unit
Between CDI and engine stop switch
Between ignition coil and spark plug
Between generator and CDI unit
★ IGNITION PRIMARY CIRCUIT
Faulty generator
Faulty CDI unit
Faulty alternator exciter coil
Loosen contacted terminals
Faulty ignition coil
★ IGNITION SECONDARY CIRCUIT
Faulty plug
Loosen contacted spark plug wire
★ IMPROPER IGNITION TIMING
Faulty generator
Faulty CDI unit
★ LOOSE, BROKEN OR SHORTED WIRE
★ FAULTY ALTERNATOR
★ FAULTY IGNITION SWITCH
★ LOOSE BATTERY CONNECTION
★ LOOSE CHARGING SYSTEM CONNECTION
★ DEAD BATTERY
★ FAULTY IGNITION SWITCH
★ LOOSE OR DISCONNECTED WIRE
★ FAULTY IGNITION SYSTEM
★ ENGINE PROBLEMS
FAULTY ENGINE STOP SWITCH
★
FAULTY REMOTE CONTROLLER
★
SCANTY CONTROLLER BATTERY
★
ELECTRIC