Adjusting The Headlight Range; Removing The Seat; Mounting The Seat; Removing The Fuel Tank - KTM 250 EXC E-Starter EU 2010 Owner's Manual

MAINTENANCE WORK ON CHASSIS AND ENGINE

Adjusting the headlight range

11.74

Removing the seat

11.75

Mounting the seat

11.76

Removing the fuel tank

x
11.77
Danger
Fire hazard Fuel is highly flammable.
–
Never refuel the vehicle near open flames or burning cigarettes, and always switch off the engine first. Be careful that no
fuel is spilt, especially on hot vehicle components. Clean up spilt fuel immediately.
–
Fuel in the fuel tank expands when warm and can escape if the tank is overfilled. See the notes on refueling.
Warning
Danger of poisoning Fuel is poisonous and a health hazard.
–
Avoid contact between fuel and skin, eyes and clothing. Do not inhale fuel vapors. If fuel gets into your eyes, rinse immedi-
ately with water and contact a doctor. Wash affected skin areas immediately with soap and water. If fuel is swallowed, con-
tact a doctor immediately. Change clothing that has come into contact with fuel. Store fuel in a suitable canister according
to regulations and keep it out of the reach of children.
–
Check the headlight setting. (
–
Loosen screw
–
Adjust the headlight range by moving the headlight.
Guideline
The boundary between light and dark must be exactly on the lower mark for an
operational motorcycle with a rider (to prepare the mark, see: Checking the head-
light setting).
Info
The headlight range may need to be corrected if luggage is carried on the
301251-10
vehicle.
–
Tighten screw
–
Remove screw
above.
500080-10
–
Hook in the front of the seat at the collar bushing of the fuel tank, lower at the rear
and simultaneously push forward.
–
Make sure that the seat is correctly locked in.
–
Mount and tighten the screw of the seat fixing.
Guideline
Remaining screws, chassis
500068-01
–
Remove the seat. (
p. 64)
.

.

. Lift up the seat at the rear, pull it back and then remove from

p. 65)
M6 10 Nm (7.4 lbf ft)
65