Installing The Fuel Tank - KTM 250 EXC E-Starter EU 2010 Owner's Manual

MAINTENANCE WORK ON CHASSIS AND ENGINE

Installing the fuel tank

x
11.78
Danger
Fire hazard Fuel is highly flammable.
–
Never refuel the vehicle near open flames or burning cigarettes, and always switch off the engine first. Be careful that no
fuel is spilt, especially on hot vehicle components. Clean up spilt fuel immediately.
–
Fuel in the fuel tank expands when warm and can escape if the tank is overfilled. See the notes on refueling.
Warning
Danger of poisoning Fuel is poisonous and a health hazard.
–
Avoid contact of the fuel with skin, eyes and clothing. Do not inhale fuel vapors. If fuel gets into your eyes, rinse imme-
diately with water and contact a doctor. Wash affected skin areas immediately with soap and water. If fuel is swallowed,
contact a doctor immediately. Change clothing that has come into contact with fuel.
–
Turn handle
–
Pull off the fuel hose.
Info
Remaining fuel may run out of the fuel hose.
–
Remove screws
–
Hang the horn and horn bracket to one side.
B00090-10
–
Remove screw
–
Remove the tube from the fuel tank vent line.
B00033-10
–
Pull both spoilers off of the sides of the radiator bracket
tank.
B00032-10
–
Position the fuel tank and fit the two spoilers to the sides of the radiator bracket.
–
Make sure that no cables are trapped or damaged.
B00032-01
of the fuel tap to the OFF position. (Figure B00089-10

with the collar sleeve.

with the collar sleeve.

66
p. 20)
and lift off the fuel
