Download Print this page

Advertisement

Quick Links

SETUP INSTRUCTIONS
2010
125 EXC EU
125 EXC SIX DAYS EU
150 XC USA
200 EXC EU
200 XC‑W USA
250 EXC EU
250 EXC SIX DAYS EU
250 XC EU/USA
250 XC‑W USA
300 EXC EU
300 EXC SIX DAYS EU
300 XC EU/USA
300 XC‑W USA
Art. no. 3211559en

Advertisement

loading
Need help?

Need help?

Do you have a question about the 250 XC EU 2010 and is the answer not in the manual?

Questions and answers

Summary of Contents for KTM 250 XC EU 2010

  • Page 1 SETUP INSTRUCTIONS 2010 125 EXC EU 125 EXC SIX DAYS EU 150 XC USA 200 EXC EU 200 XC‑W USA 250 EXC EU 250 EXC SIX DAYS EU 250 XC EU/USA 250 XC‑W USA 300 EXC EU 300 EXC SIX DAYS EU 300 XC EU/USA 300 XC‑W USA Art.
  • Page 3 KTM accepts no liability for delivery options, deviations from illustrations and descriptions, as well as misprints and other errors.
  • Page 4: Means Of Representation

    MEANS OF REPRESENTATION Symbols used The symbols used are explained in the following. Identifies an expected reaction (e.g. of a work step or a function). Identifies an unexpected reaction (e.g. of a work step or a function). Identifies a page reference (more information is provided on the specified page). Formats used The typographical and other formats used are explained below.
  • Page 5 SET‑UP Unpacking and setting up the vehicle – Remove the box and the plastic packaging. Info To avoid damaging the motorcycle during assembly, leave the protective plastic on the vehicle until you have finished. – Check the vehicle for transport damage. –...
  • Page 6 600810-10 (EXC EU) – Apply the label. – Position all controls exactly on the handlebar. Tighten all screws. – Refuel. ( p. 7) – Print out the current PDI form found on KTM DEALER.NET and perform the delivery inspection. 400730-01...
  • Page 7 WORK Removing the seat – Remove screw . Lift up the seat at the rear, pull it back and then remove from  above. 500080-10 Mounting the seat – Hook in the front of the seat at the collar bushing of the fuel tank, lower at the rear and simultaneously push forward.
  • Page 8 – Do not discard batteries with the household trash. Dispose of a defective battery in an environmentally compatible manner. Give the battery to your KTM dealer or to a recycling center that accepts used batteries. Warning Environmental hazard Hazardous substances cause environmental damage.
  • Page 9 WORK – Switch off the charger after charging. Disconnect the battery. Guideline The charge current, charge voltage and charge time must not be exceeded. Charge the battery regularly when the 3 months motorcycle is not in use – Mount the seat. ( p.
  • Page 10 WORK – Switch off the engine. – Open the filler cap. ( p. 7) – Fill the fuel tank with fuel up to measurement  Guideline Measurement of 35 mm (1.38 in)  Total fuel tank 9.5 l Super unleaded gasoline, mixed with capacity, approx.
  • Page 11: Technical Data - Tightening Torques For Chassis

    TECHNICAL DATA - TIGHTENING TORQUES FOR CHASSIS – Spoke nipple, front wheel M4.5 5… 6 Nm (3.7… 4.4 lbf ft) – Spoke nipple, rear wheel 5… 6 Nm (3.7… 4.4 lbf ft) – Remaining nuts, chassis 15 Nm (11.1 lbf ft) –...
  • Page 12 SUBSTANCES Super unleaded gasoline, mixed with 2-stroke engine oil (1:60) According to – DIN EN 228 – JASO FC ( p. 12) (1:60) Mixture ratio 1:60 2-stroke engine oil Super unleaded (ROZ 95 / RON 95 / PON 91) Super unleaded gasoline, mixed with 2-stroke engine oil (1:40) According to –...
  • Page 13: Auxiliary Substances

    AUXILIARY SUBSTANCES Long-life grease Guideline – ® KTM recommends Motorex products. Supplier ® Motorex – Fett 2000...
  • Page 14 STANDARDS JASO FC JASO FC is a classification for a 2-stroke engine oil that was specifically developed for the extreme demands of racing. Thanks to first rate synthetic esters and specially designed additives, superb combustion is achieved even under extreme operating conditions.
  • Page 15 *3211559en* 3211559en KTM-Sportmotorcycle AG 5230 Mattighofen/Austria http://www.ktm.com...