Battery Installation And Battery Typesetting (Wet Or Gel/ Agm) - Viper 50000532 User Manual

USER MANUAL

BATTERY INSTALLATION AND BATTERY TYPESETTING (WET OR GEL/ AGM)

According to the type of batteries (WET or GEL/AGM), set the machine and electronic board of the battery
charger as follows:
WET BATTERIES
1 (NOTE: Turn the DIP switch 1
and 2 both to "OFF". )
DISCOVER EV AGM
2 BATTERIES
(NOTE: Turn the DIP switch 1
to "ON" ; 2 to "OFF" .)
GENERAL GEL/AGM
3 BATTERIES
(NOTE: Turn the DIP switch 1
and 2 both to "ON" .)
NOTE
When install new batteries please refer to figure 4 to adjust the DIP switches. Otherwise the
batteries may be damaged.
Machine setting
1.
Turn the ignition key (35) to "I" and in the very first seconds of machine operation pay attention to the
following:

If the first green warning light (38) is flashing, the machine is set to GEL/AGM.

If the yellow warning light (37) is flashing, the machine is set to Discover EV AGM.

If the red warning light (36) is flashing, the machine is set to WET.

If the setting need to be changed, perform the following procedure.
2.
The factory setting is for WET batteries. If the setting correspond to the battery installation, go to step6 directly.
Otherwise, follow next steps 4~5.
3.
Remove the screws on control panel (C, Figure 4), then turn over the PCB (A Figure 4)to find the DIP switch
(B,Figure4) for setting battery type(WET or Discover EV AGM or GEL/AGM),(Refer to 1 or 2 or 3).
A
B
C
E,F
SW1
SPE charger
ON
OFF
DP1 DP2
SW1 SW2
Curve/
Battery Type
D1 D2 D1 D2
IUIa Wet On Off
IUIa Gel Exide Off Off
Off Off
IUoU AGM Off On
IUIa AGM Discover On On
only for disc machine
SW2
E,F
ON
Powerfirst charger
OFF
DP1 DP2
SW1
Curve/
Battery Type
D1 D2 D1 D2
IUIa Wet On Off
IUIa Gel Exide Off Off
IUUa AGM Off On
IUIa AGM Discover On On
B
C
D
Figure 4
A
B
E,F
SPE charger
SW2
SW1
Curve/
Battery Type
D1
IUIa Wet On Off
IUIa Gel Exide Off Off
Off Off
IUoU AGM Off On
IUIUo AGM Discover On
Figure 4.1
13
A
C
SW1 SW2
ON ON
Powerfirst charger
OFF OFF
DP1 DP2 DP1 DP2
Curve/
SW2
Battery Type
D2 D1 D2
IUIa Wet
IUIa Gel Exide
Off On
IUUa AGM
IUIa AGM Discover
On
only for orbital machine
ENGLISH
E,F
SW1 SW2
D1 D2 D1 D2
On Off
Off Off
Off Off
Off On
On On