Data Aire gForce Ultra Installation, Operation & Maintenance Manual page 7

TABLE OF CONTENTS
TABLE OF FIGURES
Figure 1 Typical Upper Spring-Loaded Hinge ..................................................................................... 16
Figure 2 Upper Hole for Spring-Loaded Hinge .................................................................................... 17
Figure 3 Lower Fixed Pin Hinge .......................................................................................................... 17
Figure 4 Example of Lifting Method .................................................................................................... 18
Figure 5 Typical Return & Discharge Air Distribution .......................................................................... 20
Figure 6 Typical Check Valve ............................................................................................................. 23
Figure 7 Typical Remote Condenser Above Evaporator Installation ................................................... 26
Figure 8 Typical Remote Condenser Below Evaporator ..................................................................... 27
Figure 9 Typical Water/Glycol System ................................................................................................ 31
Figure 10 Recommended Condensate Trap Dimensions ................................................................... 34
Figure 11 Typical Remote Heat Exchanger Interconnection Points .................................................... 40
Figure 12 Typical Indoor Evaporator Interconnection Points............................................................... 41
Figure 13 Manual Override Switch Board ........................................................................................... 44
Figure 14 EEV with Electrical Mating Connector ................................................................................. 45
Figure 15 Typical VFD to VS Compressor Wiring ............................................................................... 52
Figure 16 Typical Low Ambient Receiver Package ............................................................................. 64
Figure 17 CDS-803 Drive P/N 101-260-230 or 460-VFD (22 kW Ultra units)...................................... 77
Figure 18 CDS-303 Drive P/N Various (36 to 125 kW Ultra units) ...................................................... 78
Figure 19 Danfoss Model CDS-803 Modbus Point List for dap4 ......................................................... 79
Figure 20 Danfoss Model CDS-303 Modbus Point List for dap4 ......................................................... 80
Figure 21 Danfoss VFD MCB105 Relay Card ..................................................................................... 80
Figure 22 Typical EVD Display View ................................................................................................... 96
Figure 23 Example Remote EPO Switch Connection ....................................................................... 117
7