Ansi Safety Signs - Terex PT30 Operation And Maintenance Manual

2 SAFETY

2.4 ANSI Safety Signs

The safety signs are located in/on the machine as indicated. (Descriptions of the
symbols are provided in section 2.3)
3
Improper operation or maintenance can re-
sult in serious injury or death.
Read and understand the operator's manual
and all safety signs prior to operating or
maintaining the machine.
2
Crush Hazard
Falling can result in serious injury or death
Rollover can crush and result in serious injury or death.
Do not use the bucket/attachment as a work platform.
Fasten Seat Belt
1
Fall Hazard
Use the provided access system when
Serious injury or death can result
entering or exiting the machine.
from falling.
2030-597
11
Read Operator's manual
Fire Hazard
Keep engine, exhaust and chassis
Flammable debris can collect near hot
areas free of debris.
components and lead to a fire.
2030-599
10
Key
1. Fall hazard
2. Crush / fall hazards (inside cab enclosure)
3. Fall / rollover hazards / read operator's manual (inside cab enclosure)
4. Skin (oil) injection hazard
5. Explosion / burn hazard (read operator's manual) (engine compartment)
6. Clean undercarriages notice
7. Crush hazard (run over)
8. Crush hazard (lift arm brace)
9. Crush hazard (lift arms)
10. Tie down locations (on chassis, beneath lift arm)
11. Fire hazard (read operator's manual) (inside cab enclosure)
Rollover/Ejection Hazard
Fall Hazard
Serious injury or death can result.
Falling from a machine can result in serious
.
injury or death
Read Operator's Manual
Carry loads low. Load unload and turn on
level ground. Travel on inclines with heaviest
No Riders
end of machine uphill.
Fall Hazard
.
2030-596
9
Crush Hazard
Death or serious injury can result
from contact with moving lift arm or
attachment.
4
Injection Hazard
Escaping fluid under pressure can
penetrate skin, causing serious injury.
2030-598
Keep clear of lift arms and
attachments.
2030-592
14
• Relieve internal pressure before
disconnecting any line or fitting.
• Keep away from leaks or pinholes.
• Use cardboard to check for leaks.
Fluid injected into skin must be surgi-
cally removed within a few hours by a
doctor familiar with this type of injury
or gangrene will result.
2030-602
5
Explosion/Burn Hazard
Will cause death, burns or
blindness due to ignition of
explosive gasses or contact
with corrosive acid.
• Keep all flames/sparks
away!
• No Smoking!
• Read and understand
all manuals prior to
operation.
2030-603
6
NOTICE
Inspect undercarriages daily for
accumulation of debris. If debris
is present, clean thoroughly with
a pressure washer. If debris is
allowed to build up, it can cause
premature component wear and
decrease machine performance.
2085-253
7
CRUSH HAZARD
Contact with moving machine can Keep clear of moving machine.
result in death or serious injury.
8
Crush Hazard
Death or serious injury can result
from contact with moving lift arm or
Install lift arm brace prior to servicing.
attachment.
2030-594
2030-593