Table of Contents
Advertisement
After running the engine for the first time, stop the engine and monitor the
water level frequently as trapped air bubbles may be expelled. Top up the system
as necessary.
14. Control Cables
• Connect engine speed control cable. With the engine off, ensure that the engine speed
control lever achieves full travel from idle to full speed. Adjust if necessary.
• Check the gearbox shift lever selects positively and that the drive direction
corresponds with the gearshift control lever. Ensure that the gearbox control lever and
the gearshift lever are both in neutral before connection. Adjust if necessary.
15. Domestic Battery Bank
EXPLOSION HAZARD! NEVER SHORT OUT THE BATTERY TERMINALS,
INCLUDING WHEN CHECKING THE REMAINING BATTERY CHARGE THIS WILL
RESULT IN A SPARK AND MAY CAUSE AN EXPLOSION OR FIRE.
BURN HAZARD! BATTERIES CONTAIN SULPHURIC ACID. NEVER ALLOW
BATTERY FLUID TO COME IN CONTACT WITH SKIN, EYES OR CLOTHING. SEVERE
BURNS COULD RESULT. MAKE SURE THE CORRECT PERSONAL PROTECTION
Domestic battery banks that are too large create excessive loads on the domestic alternator.
Alternators running at maximum output for prolonged periods of time will eventually fail
prematurely; alternators that fail due to the battery bank being over the maximum
recommended size will not be covered by warranty.
Higher output additional alternators, or 'E' kits are available: if larger battery banks are
required discuss your individual power requirements with the boat builder or engine supplier.
• The maximum domestic battery bank is calculated using the following:
-
Live aboard, three times domestic alternator, maximum output current.
-
Weekend cruising or hire fleet use, three and a half times domestic
RDG603A81 – Issue 2
DANGER:
WARNING:
EQUIPMENT IS WORN.
Page 29 of 93
Advertisement
Table of Contents
