Troubleshooting The Filterquick With Fingertip Filtration; Incomplete Filtration - Frymaster FilterQuick 5FQG30U Installation, Operation And Maintenance Manual

A FilterQuick™ controller controls the semi-automatic filtration system on the FilterQuick™ fryer.
After a preset number of cook cycles the controller displays Filter now? alternating with
YES NO. If NO is selected or a cook cycle is started, the controller will resume normal
operation for a set amount of cooks and the prompt for a filter again. The FILTER NOW? prompt is
displayed once the cooks til filter or filter prompt count is satisfied. Refer to page 1-12 of the
FilterQuick™ controller manual 819-7206 for filter steps. All messages need to be confirmed or
cleared on all controllers prior to starting any filtration process.
4.4 Troubleshooting the FilterQuick

4.4.1 Incomplete Filtration

Should the filter procedure fail after the filter paper or pad was changed an error message is
generated.
The controller displays IS VAT FULL? alternating with yes no.
The MIB board displays three horizontal lines.
1. If the vat is full press the 
returns to idle cook mode or OFF.
If the pot is not filled completely continue to next step.
2. Press 
(NO)
if pot is not filled completely.
The controller displays FILLING while the pump runs again. When the pump stops, the controller
displays IS VAT FULL? alternating with yes no again. If the vat is full go to step 1. If the
vat is not completely filled continue.
3. Press 
(NO)
if pot is not filled completely.
The controller displays FILLING while the pump runs again. When the pump stops, the controller
displays IS VAT FULL? alternating with yes no again. If the vat is full go to step 1. If the
vat is not completely filled continue.
4. Press 
(NO)
if pot is not filled completely. If this is the sixth
consecutive sequence of incomplete filtration skip to step 8.
The controller displays CHANGE FILTER PAPER? alternating with YES NO and an
alarm.
5. Press 
(YES)
to continue.
Pressing 
(NO)
allows the fryer to return to cook mode in most cases for
four minutes or 15 minutes if the paper is expired*, ending with the
CHANGE FILTER PAPER? alternating with YES NO display.
This repeats until YES is chosen.
™
with Fingertip Filtration
(YES)
button to continue. The controller
4-3