Will Burt POSITIONIT PI-150 Operator's Manual page 10

I PI-150 PI-75
P OSITION T AND
Crush Hazard! Do not stand directly beneath the positioner or payload. Be certain payload is
properly installed and secured. In locations or areas where the risk of injury occurs, or any part
of the assembly may become detached or fall for any reason, a strong safety chain or wire
hawser should be attached between the equipment and the mounting surface. At all times,
normal safety precautions must be employed. Death or serious injury could result if positioner
fails suddenly.
Safety Equipment! Helmets or hard hats, eye protection, gloves, and safety shoes or combat
boots must be properly worn while working in the deployment area. Death or serious injury
could result if proper safety equipment is not properly worn.
Trained Personnel Only! Installation, operation, and maintenance to be performed by trained
and authorized personnel only. Death or serious injury could result if proper installation,
inspection, operation, and maintenance procedures are not observed.
Lifting Hazard! Manually lifting over 55 lb. (25kg) is prohibited. In the UK, all lifting equipment
must be thoroughly examined annually by a competent person according to the Lifting
Operations and Lift Equipment Regulations 1998. Equivalent regulations exist in other EU
states.
Safety Instruction – Remote Control! The equipment is subject to remote control and may be
operated at any time. Persons working on the equipment should take appropriate precautions to
ensure that any unexpected movement does not occur as this could lead to injury.
Equipment Damage! All persons installing and maintaining this equipment should be suitably
qualified and work to national and local standards and codes of practice.
Equipment Damage! Each positioner contains a 1.85 amp self-resetting circuit breaker to
protect the PC board. Do not disassemble the positioner side plates, or separate from the
pedestal. Doing so will break the environmental seal and potentially cause improper stop limit
settings. This will void the warranty.
viii TP-5129001-J
January 2022