Component List; Specifications - Handicare PRISM MEDICAL C450 Owner's Manual

Component List

The following components are included with your new
C450/ C625
lift (Manual or Motorized traverse)
•
• Pneumatic Hand Control
• Lift Charger (mounted on the wall or ceiling at the end of the track)
• Owner's Manual
• Warranty Card
SLINGS: If a sling has been supplied with the lift refer to the instructions included with the sling.
ACCESSORIES: If additional accessories such as a turntable, or gate system have been supplied with the lift
refer to the instructions included with those items.
IMPORTANT: Before initial use, the lift unit must be charged for 4 hours. Refer to section titled
Charging Instructions
"
connected refer to the section titled "
Specifications of C450/ C625 lift
Lift Motor:
Traverse Motor:
"H" Frame Traverse Motor:
Charger Alternate 1 Model:
Charger Alternate 1 Input:
Charger Alternate 1 Output:
Charger Alternate 2 Model:
Charger Alternate 2 Input:
Charger Alternate 2 Output:
Charger Alternate 3 Model:
Charger Alternate 3 Input:
Charger Alternate 3 Output:
Batteries:
Lift Case:
Hand Control:
Lifting Range:
Lift Weight:
Maximum Load:
Duty Cycle:
Rated Performance:
Max Sound Level:
Service Life:
C450/ C625 - User Guide (753101)
". The hand control airline tube must also be connected to the lift. If it is not
Connecting airline to the lift
24 VDC
24 VDC (Optional at time of Purchase)
24 VDC (Optional at time of Purchase)
Soneil, 2403SRM30
100-240 VAC, 1.5 Amps, 50-60 Hz
24 VDC, 1.5 Amps
Soneil, 2403SRM20
100 VAC 0.45 Amps, 240 VAC 0.22 Amps, 50-60 Hz
28.8 VDC, 1 Amp
Mascot, 9940
100-240 VAC, 0.9 Amps, 50-60 Hz
29.5 VDC, 1.3 Amps
24 VDC (2 x 12 VDC) 5.0 AH, Sealed Lead Acid
Flame Retardant ABS
Pneumatic
Up to 96" (2438mm)
21—23.5 lbs.(9.5-10.65Kg)
Standard maximum load 450lbs (204 Kgs). Also available in 625 lbs(283 Kgs).
1 Min "ON"-9 Mins "OFF"
30-40 lifts at 625 lbs.(283 Kgs) , 50-60 lifts at 450 lbs.(204 Kgs) , 1 Min "ON"-9 Mins
"OFF" duty cycle, each lift being 24 inches/610mm at the middle of the lifting range
(from 54"/1370mm strap out to 30"/762mm strap out) per full battery. Please note: the
lift has a break in period; breaking in of the lift will need to be done before these
numbers will be achieved. The breaking in period will vary from lift to lift and is
dependent on the frequency of use and the types of load being applied, the higher the
load and a greater frequency of use will break in the lift faster.
Raising Max load 56.1 dB , Lowering Max load 60.3 dB .
22500 Cycles or 10 years , whichever comes earlier.
As a precautionary measure, the lifting strap should be replaced every 5000 cycles or 3
years, whichever comes earlier. Higher usage lifts may necessitate more frequent
replacement of the lifting strap; please refer to pages 26-27 for General Inspection and
Maintenance information.
Rev: 14 MAR 2017
C450/ C625
lift system:
".
Shipping/Storage Conditions:
Temperature:
Relative Humidity:
Atmospheric Pressure: 500 to 1060 hPa
Maximum load of the installed lift is
determined by referring to the product
label located on side of lift.
-40 to +70 ºC
10 to 100% RH
Page: 4