Kohler 6VSG Service Manual page 18

Figure 2-1
System Component or Procedure
Fuel
Flexible lines and connections
Main tank supply level (if LPG fueled)
Fuel piping
Lubrication
Oil level
Crankcase breather hose
Change oil
Replace filter
Cooling
Air ducts, louvers
Exhaust Line
Leakage
Insulation, fire hazards
Obstructions or combustible materials near exhaust
outlet
DC Electrical System
Battery charger operation, charge rate (if equipped)
Remove corrosion, clean and dry battery and rack
Clean and tighten battery terminals and inspect boots
Battery electrolyte level and specific gravity *
AC Electrical System
Tighten control and power wiring connections
Remote control system (if equipped)
Visible wear or damage
Wire abrasions where subject to motion
Wire-cable insulation condition
Engine and Mounting
Visible wear or damage
Air cleaner and precleaner service †
Spark plugs
Replace stepper motor coupling and bushing
Generator
Visible wear or damage
Exercise generator set
Brushes and collector ring
Measure and record resistance readings of windings
with insulation tester (Megger
rectifier and load leads disconnected) *
General Condition of Equipment
Evidence of vibration, leakage, excessive noise,
temperature, or deterioration
Interior of sound enclosure
* Not necessary for maintenance-free batteries.
† Service more frequently under extremely dusty/dirty conditions.
‡ Yearly or 250 hours if equipped with optional oil makeup kit.
** Every 24 hours of operation if equipped with optional oil makeup kit.
Megger ® is a registered trademark of Biddle Instruments.
Figure 2-1 Service Schedule
18 Section 2 Scheduled Maintenance
Section
®
, with SCR assembly or
Procedure
See
Visually
Inspect Check Change
X
X
X
2.2
X X
X
2.6
X
2.7
X X
X
X
2.9
X
X
X X
X
X
X
X X
X
X
2.5
2.4
X
D
X X
X
X Action
D Authorized distributor/dealer only
R Replace as necessary
Clean Test
R
before use**
Yearly or 500 hours
X Yearly or 100 hours ‡
X Yearly or 200 hours
X
X
X
3 years or 500 hours
R Yearly or 100 hours
X Yearly or 300 hours
D
X
D
D
X
X
Frequency
Quarterly
Weekly
Yearly
8 hours or
Yearly
Weekly
Yearly
Weekly
Monthly
Yearly
Yearly
Yearly
Yearly
Monthly
Quarterly
6 months
Weekly
500 hours
Quarterly
Weekly
Yearly
3 years
Weekly
Quarterly
TP-6844 1/13