Advertisement

Quick Links

IDC175-HD TOWER DISPENSER
Operator's Manual
Release Date: May 09, 2014
Publication Number: 621058513OPR
Revision Date: June 10, 2015
Revision: 9

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the IDC175-HD and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Summary of Contents for Cornelius IDC175-HD

  • Page 1 IDC175-HD TOWER DISPENSER Operator’s Manual Release Date: May 09, 2014 Publication Number: 621058513OPR Revision Date: June 10, 2015 Revision: 9...
  • Page 2 Commercial Warranty. Cornelius will not be responsible for any repair, replacement or other service required by or loss or damage resulting from any of the following occurrences, including but not limited to, (1) other than normal and proper use and normal...
  • Page 3: Table Of Contents

    IDC175-HD Tower Ice Drink Dispenser ........
  • Page 4 5. Sanitizing Cycle ............11 6.
  • Page 5: Safety Instructions

    Only trained and certified electrical, plumbing and refrigeration technicians should service this unit. ALL WIRING AND PLUMBING MUST CONFORM TO NATIONAL AND LOCAL CODES. FAILURE TO COMPLY COULD RESULT IN SERIOUS INJURY, DEATH OR EQUIPMENT DAMAGE. © 2014-2015, Cornelius Inc. - 1 - Publication Number: 621058513OPR...
  • Page 6: Safety Precautions

    If the power cord is damaged, it must be replaced with special cord available from the manufacturer or its service agent. OUND EVEL CAUTION: The A-weighted sound pressure level has been determined to be below 70dBA Publication Number: 621058513OPR - 2 - © 2014-2015, Cornelius Inc.
  • Page 7: General Instructions

    PECIFICATIONS The IDC175-HD tower is a high capacity ice drink dispenser with two different drink dispensing sides. One side is for the drive through and the other one is for the store. Both sides are crew operated. The IDC 175-HD tower dispenser has 8 SFV1/LVV portion control valves and a Progate ice chute on each side.
  • Page 8: Control Box Functions

    HD Tower Dispenser Operator’s Manual ONTROL UNCTIONS The portion control box on the IDC175-HD Tower Dispenser has several functions including dispensing four programmed ice portions for four cup sizes, programming, and a manual dispense mode. Ice Portion Dispense Buttons Pour/Cancel Button Programming Button Portion Control Keys (decrease) Portion Control Keys (increase) Ice Portion Bar...
  • Page 9: Cleaning And Maintenance Instructions

    : (D ISPENSING ALVES AILY LEANING AND ONTHLY LEANING Refer to the addendum supplied with the unit that is applicable to the manufacturer of the valves installed on the unit. © 2014-2015, Cornelius Inc. - 5 - Publication Number: 621058513OPR...
  • Page 10: Lid Dispenser Cleaning

    6. Align latches, push side tabs down to lock in place. NOTE: If agitator or the ice chute does not operate, remove and reinstall the chute cover. Figure 4 Publication Number: 621058513OPR - 6 - © 2014-2015, Cornelius Inc.
  • Page 11: Monthly Cleaning: (In Addition To Daily Cleaning Procedures)

    9. Remove the sanitizing fittings from the BIB disconnects and connect them to the appropriate BIB container. Operate the valves until all of the sanitizing solution has been flushed from the system and the syrup is flowing freely. © 2014-2015, Cornelius Inc. - 7 - Publication Number: 621058513OPR...
  • Page 12: Yearly Maintenance

    Fill Bucket # 3 (Sanitizer Solution) to the top. Place the ice collection trays under both of the ice dispensing chutes. Locate clean hose assembly Figure 5 Figure 6 Figure 7 Publication Number: 621058513OPR - 8 - © 2014-2015, Cornelius Inc.
  • Page 13: Ice Hopper Cleaning Entry Sub Cycle

    L2 LED will start flashing, signaling that it is ready to proceed to the next Chute step. Remove the collection trays. Place the funnel under both of the ice dispense chutes. Place funnel here Figure 12 © 2014-2015, Cornelius Inc. - 9 - Publication Number: 621058513OPR...
  • Page 14: Rinse Cycle

    (see Figure 19). IMPORTANT: Before starting, make sure the hose is placed all the Figure 17 way to the bottom of the bucket which contains cleaning solution Figure 18 Figure 19 Publication Number: 621058513OPR - 10 - © 2014-2015, Cornelius Inc.
  • Page 15: Sanitizing Cycle

    (see Figure 25). Figure 23 IMPORTANT: Before starting, make sure the hose is placed all the way to the bottom of the bucket which contains cleaning solution. Figure 24 Figure 25 © 2014-2015, Cornelius Inc. - 11 - Publication Number: 621058513OPR...
  • Page 16: End Cycle

    IMPORTANT: Do not put the ice chute cover into a dish washer. Figure 29 Spray sanitizer on the ice chute cover at the front and back surfaces. Wipe clean with a soft cloth. Let it air dry for 5 minutes. Publication Number: 621058513OPR - 12 - © 2014-2015, Cornelius Inc.
  • Page 17: Drain And Refill The Water Bath

    After the water bath is fully drained, locate the strainer which connects to the recirculation pump inlet. Inspect the strainer to see if any debris is accumulated. NOTE: It is recommended to clean the strainer during each cleaning cycle. Figure 33 © 2014-2015, Cornelius Inc. - 13 - Publication Number: 621058513OPR...
  • Page 18 Figure 34 Figure 35 Turn the drain lever back to the original position (OFF) and fill the water bath with fresh water. Figure 36 Publication Number: 621058513OPR - 14 - © 2014-2015, Cornelius Inc.
  • Page 19: Plumbing Schematic

    HD Tower Dispenser Operator’s Manual LUMBING CHEMATIC © 2014-2015, Cornelius Inc. - 15 - Publication Number: 621058513OPR...
  • Page 20: Electrical Schematic

    HD Tower Dispenser Operator’s Manual LECTRICAL CHEMATIC Publication Number: 621058513OPR - 16 - © 2014-2015, Cornelius Inc.
  • Page 21: Troubleshooting

    3. Check the gate cylinder for free movement. 1. Check the wire connections from agitator capacitor, transformer, and terminal block in the e-box to the agitator motor. 2.Check if the keypad buttons are functional. © 2014-2015, Cornelius Inc. - 17 - Publication Number: 621058513OPR...
  • Page 22: Beverage Not Dispensing

    HD Tower Dispenser Operator’s Manual EVERAGE ISPENSING Publication Number: 621058513OPR - 18 - © 2014-2015, Cornelius Inc.
  • Page 23: Flat Drinks

    Is there ice in the water bath ? 1. Fill the hopper with ice. 2. Dispense some ice to ensure that the agitator pushes ice in the water bath. © 2014-2015, Cornelius Inc. - 19 - Publication Number: 621058513OPR...
  • Page 24 HD Tower Dispenser Operator’s Manual Publication Number: 621058513OPR - 20 - © 2014-2015, Cornelius Inc.
  • Page 26 Cornelius Inc. www.cornelius.com...

Table of Contents