Cornelius ED 300 BC Installation Manual
Ice/beverage dispenser
Hide thumbs
Also See for ED 300 BC:
- Installation manual (22 pages) ,
- Operator's manual (16 pages) ,
- Installation manual (22 pages)
Table of Contents
Related Manuals for Cornelius ED 300 BC
Summary of Contents for Cornelius ED 300 BC
- Page 1 INSTALLATION MANUAL BEVERAGE ISPENSER Model: ED 300 BC Release Date: March 25, 2004 Publication Number: 92166INS Revision Date: January 14, 2015 Revision: G Visit the Cornelius web site at www.cornelius.com for all your Literature needs.
-
Page 2: Contact Information
Commercial Warranty. Cornelius will not be responsible for any repair, replacement or other service required by or loss or damage resulting from any of the following occurrences, including but not limited to, (1) other than normal and proper use and normal... -
Page 3: Table Of Contents
Flavor dispenses for more than 1 sec ..........14 Publication Number: 92166INS © 2004-2015, Cornelius Inc. - Page 4 Wiring Schematic (220--240 V Unit) ..........20 ©2004-2015, Cornelius Inc.
-
Page 5: Safety Instructions
Only trained and certified electrical, plumbing and refrigeration technicians should service this unit. ALL WIRING AND PLUMBING MUST CONFORM TO NATIONAL AND LOCAL CODES. FAILURE TO COMPLY COULD RESULT IN SERIOUS INJURY, DEATH OR EQUIPMENT DAMAGE. Publication Number: 92166INS - 1 - © 2004-2015, Cornelius Inc. -
Page 6: Safety Precautions
NOTE: Many units incorporate the use of additional equipment such as icemakers. When any addition equipment is used you must check with the equipment manufacturer to determine the additional weight the counter will need to support to ensure a safe installation. ©2004-2015, Cornelius Inc. - 2 - Publication Number: 92166INS... -
Page 7: Description
220-240/1/50/60 Hz, 2.6 Amps Total Unit Draw Dimensions ED 150: 44-3/8 in. Wide X 31-1/2 in. Deep X 37 in. High Z model = 44-3/8 in. Wide X 23-1/16 in. Deep X 37 in. High Publication Number: 92166INS - 3 - © 2004-2015, Cornelius Inc. -
Page 8: Installation Instructions
8. The dispenser is not designed for a wash down environment and must not be placed in an area where a water jet could be used. 9. The unit has to be placed in a horizontal position. ©2004-2015, Cornelius Inc. - 4 - Publication Number: 92166INS... -
Page 9: Adjust Water-To-Syrup Ratio
15. Set a syrup flow adjuster to get the desired ratio. 16. Test the valve and adjust until a consistent ratio is delivered three consecutive times. 17. Repeat procedure for other valves. Publication Number: 92166INS - 5 - © 2004-2015, Cornelius Inc. -
Page 10: Gate Restrictor Plate
Ice/Beverage Dispenser Installation Manual GATE RESTRICTOR PLATE CAUTION: Disconnect power to dispenser before installing, removing or adjusting restrictor. See safety section of this manual. Figure 2. Gate Restrictor Plate ©2004-2015, Cornelius Inc. - 6 - Publication Number: 92166INS... -
Page 11: Adjustment
Adjustment can be made by sliding up or down with nuts loosened, to obtain the desired amount of restriction. Figure 3. Mounting Template (Ice only-B Models) Figure 4. Mounting Template (BC Models) Publication Number: 92166INS - 7 - © 2004-2015, Cornelius Inc. -
Page 12: Drip Tray Drain Assembly
Ice/Beverage Dispenser Installation Manual Figure 5. Drip Tray Drain Assembly ©2004-2015, Cornelius Inc. - 8 - Publication Number: 92166INS... -
Page 13: Flow Diagram (Bc Model With Eight Beverage Faucets)
Ice/Beverage Dispenser Installation Manual Figure 6. Flow Diagram (BC Model with Eight Beverage Faucets) Publication Number: 92166INS - 9 - © 2004-2015, Cornelius Inc. -
Page 14: Flow Diagram (B Models With Ten Beverage Faucets)
Ice/Beverage Dispenser Installation Manual Figure 7. Flow Diagram (B Models with Ten Beverage Faucets) ©2004-2015, Cornelius Inc. - 10 - Publication Number: 92166INS... -
Page 15: Flow Diagram (Bc Models With Twelve Beverage Faucets)
Ice/Beverage Dispenser Installation Manual Figure 8. Flow Diagram (BC Models with Twelve Beverage Faucets) Publication Number: 92166INS - 11 - © 2004-2015, Cornelius Inc. -
Page 16: Flow Diagram (B Models With Twelve Beverage Faucets)
Ice/Beverage Dispenser Installation Manual Figure 9. Flow Diagram (B Models with Twelve Beverage Faucets) ©2004-2015, Cornelius Inc. - 12 - Publication Number: 92166INS... -
Page 17: Troubleshooting
C. Defective flow control. Flavor dispenses more than .5 oz A. Dip switch settings on control board incorrect. B. Flow control incorrectly set. C. PC board defective. D. Defective flow control. Publication Number: 92166INS - 13 - © 2004-2015, Cornelius Inc. -
Page 18: Flavor Syrups Do Not Dispense
Defective PC board. G. Defective harness from keypad. H. Defective Flow control. Defective solenoid harness. Defective keypad. Contact your local syrup or beverage equipment distributor for additional information and troubleshooting of beverage system. ©2004-2015, Cornelius Inc. - 14 - Publication Number: 92166INS... -
Page 19: Wiring Diagram (120 V Unit)
Ice/Beverage Dispenser Installation Manual Figure 10. Wiring Diagram (120 V Unit) Publication Number: 92166INS - 15 - © 2004-2015, Cornelius Inc. -
Page 20: Wiring Schematic (120V Unit)
Ice/Beverage Dispenser Installation Manual Figure 11. Wiring Schematic (120V Unit) ©2004-2015, Cornelius Inc. - 16 - Publication Number: 92166INS... -
Page 21: Wiring Diagram (220--240 V Unit)
Ice/Beverage Dispenser Installation Manual Figure 12. Wiring Diagram (220--240 V Unit) Publication Number: 92166INS - 17 - © 2004-2015, Cornelius Inc. - Page 22 Ice/Beverage Dispenser Installation Manual Figure 13. ©2004-2015, Cornelius Inc. - 18 - Publication Number: 92166INS...
-
Page 23: Wiring Schematic (220--240 V Unit)
Ice/Beverage Dispenser Installation Manual Wiring Schematic (220--240 V Unit) Figure 14. Publication Number: 92166INS - 19 - © 2004-2015, Cornelius Inc. - Page 25 Cornelius Inc. www.cornelius.com...