Cornelius IDC 255 PROGATE DRIVE THRU Operator's Manual
Hide thumbs
Also See for IDC 255 PROGATE DRIVE THRU:
- Installation manual (40 pages) ,
- Operator's manual (18 pages) ,
- Installation manual (39 pages)
Table of Contents
Related Manuals for Cornelius IDC 255 PROGATE DRIVE THRU
Summary of Contents for Cornelius IDC 255 PROGATE DRIVE THRU
- Page 1 ® IDC 255 PROGATE DRIVE THRU Operator’s Manual Release Date: June 28, 2006 Publication Number: 621057419OPR Revision Date: August 3, 2010 Revision: B Visit the IMI Cornelius web site at www.cornelius.com for all your Literature needs.
-
Page 2: Contact Information
Commercial Warranty. Cornelius will not be responsible for any repair, replacement or other service required by or loss or damage resulting from any of the following occurrences, including but not limited to, (1) other than... -
Page 3: Table Of Contents
TABLE OF CONTENTS Safety Instructions ............1 Read and Follow all Safety Instructions . -
Page 4: Safety Instructions
Only trained and certified electrical, plumbing and refrigeration technicians should service this unit. ALL WIRING AND PLUMBING MUST CONFORM TO NATIONAL AND LOCAL CODES. FAILURE TO COMPLY COULD RESULT IN SERIOUS INJURY, DEATH OR EQUIPMENT DAMAGE. © 2006, IMI Cornelius Inc. - 1 - Publication Number: 621057419OPR... -
Page 5: Safety Precautions
NOTE: Many units incorporate the use of additional equipment such as icemakers. When any addition equipment is used you must check with the equipment manufacturer to determine the additional weight the counter will need to support to ensure a safe installation. Publication Number: 621057419OPR - 2 - © 2006, IMI Cornelius Inc. -
Page 6: Unit Requirements
4 lid dispenser locations on the unit • 3 Separate removable lid dispensers for small/medium, large, and extra large lids Straw Holder • Holds up to 140 regular sleeved straws © 2006, IMI Cornelius Inc. - 3 - Publication Number: 621057419OPR... -
Page 7: Start-Up And Operating Instructions
The lid dispensers are designed to be removed from the front of the merchandiser to make loading the dispensers simpler and allow for cleaning of the merchandiser and lid dispensers. The dispensers can be arraigned in any configuration with room for four on the merchandiser face. Publication Number: 621057419OPR - 4 - © 2006, IMI Cornelius Inc. -
Page 8: Loading Of Lid Dispenser
Tear open bag. FIGURE 4 Slide sleeve into tube Pull plastic from stack replace top and place lid dispenser back in position on the merchandiser. FIGURE 5 FIGURE 6 © 2006, IMI Cornelius Inc. - 5 - Publication Number: 621057419OPR... -
Page 9: Individual Lids
Turn dispenser upside down and trap lids in the tube. FIGURE 8 Place your hand over the top to capture lids and turn it right side up. FIGURE 9 Publication Number: 621057419OPR - 6 - © 2006, IMI Cornelius Inc. -
Page 10: Lid Dispenser Operation
To dispense a lid: Place hand in finger slot Grab edge of lid and pull. FINGER BASE GUIDE POSITION 3 LID SUPPORT POSITION 2 LID PIVOT POINT POSITION 1 FIGURE 10 © 2006, IMI Cornelius Inc. - 7 - Publication Number: 621057419OPR... -
Page 11: Cleaning And Maintenance Instructions
IDC 255 Progate Drive Operator’s Manual CLEANING AND MAINTENANCE INSTRUCTIONS These instructions are used on all Cornelius ice drink dispensers. Some models may have additional cleaning requirements. Those models will have addition procedures listed later in the manual. WARNING: Disconnect power to the unit before cleaning or servicing following all lock out / tag out procedures established by the user. -
Page 12: Monthly Cleaning
6. Install and properly position the access covers on the cold plate. 7. Install the splash panel in the reverse order it was removed. 8. Rinse cold plate surface by pouring potable water through hopper openings. © 2006, IMI Cornelius Inc. - 9 - Publication Number: 621057419OPR... -
Page 13: Dispensing Valves (Daily Cleaning)
9. Remove the sanitizing fittings from the B–I–B disconnects and connect the disconnects to the appropri- ate B–I–B container. Operate the valves until all sanitizer has been flushed from the system and syrup is flowing freely. Publication Number: 621057419OPR - 10 - © 2006, IMI Cornelius Inc. -
Page 14: Replenishing Co2 Supply
<100F. IMPORTANT: Do not put the ice chute into a dishwasher. Replace when finished. If agitator or ice chute does not operate remove and reinstall chute cover. FIGURE 11 © 2006, IMI Cornelius Inc. - 11 - Publication Number: 621057419OPR... -
Page 15: Progate 2 Control Box Operation
Once the user releases the portioned button then the red light goes out. Portion Up/Down Buttons: The program bar is only active in the program mode to change the ice dispense program size. Publication Number: 621057419OPR - 12 - © 2006, IMI Cornelius Inc. -
Page 16: Programming (Changing) The Ice Portion
Place a cup under the ice chute and press the just programmed dispense size button amount dispense amount is not the desired amount repeat the process. © 2006, IMI Cornelius Inc. - 13 - Publication Number: 621057419OPR... -
Page 17: Agitation Time
(mS) (mS) 1120 1440 1760 2080 2400 2720 3040 3360 3680 Dispense Rime Agitation Time Agitation Ratio (mS) (mS) 1400 1960 2520 3080 3640 4200 4760 5320 5880 6440 Publication Number: 621057419OPR - 14 - © 2006, IMI Cornelius Inc. -
Page 18: Programming (Changing) The Agitation Time
. The LED meter shows the existing agitation ratio enabling the user to. Vary the agitation time using the directional arrow buttons. Left to decrease and right direction arrow button to increase. © 2006, IMI Cornelius Inc. - 15 - Publication Number: 621057419OPR... -
Page 19: Ice Portion Bar
=20mS “S” Small 50mS 230mS “M” Medium 80mS 260mS “L” Large 150mS 330mS “XL” XLarge 230mS 410mS FIGURE 14 Publication Number: 621057419OPR - 16 - © 2006, IMI Cornelius Inc. - Page 21 IMI Cornelius Inc. www.cornelius.com...
Need help?
Do you have a question about the IDC 255 PROGATE DRIVE THRU and is the answer not in the manual?
Questions and answers