Page 1
ITEM # GEN3000IOF 3000 Surge Watts / 2850 Running Watts GAS FUEL INVERTER GENERATOR INSTRUCTION MANUAL READ ALL INSTRUCTIONS AND WARNINGS BEFORE USING THIS PRODUCT. This manual provides important information on proper operation & maintenance. Every effort has been made to ensure the accuracy of this manual. These instructions are not meant to cover every possible condition and situation that may occur.
Page 2
Rated Watts (W) 2850 Rated Frequency (Hz) Phase Single USB Output Voltage (V) 5V 2.1A Engine Engine Type 4-stroke single cylinder with forced air cooling system Ignition System Non-contact transistor (C.D.I.) Starting System Recoil ITEM # GEN3000IOF Portable Gas Fuel Inverter Generator...
Changing Fuel Line ..............................20 Spark Plug Maintenance ............................20 Emptying The Fuel Tank ............................20 STORAGE/TRANSPORT PROCEDURES ........................21 TROUBLESHOOTING ..............................22 PARTS DIAGRAM ................................25 EMISSION CONTROL SYSTEM WARRANTY ......................... 38 ITEM # GEN3000IOF Portable Gas Fuel Inverter Generator...
Parts replaced during warranty repairs will be considered as part of the original product and will have the same warranty period as the original product. This warranty gives you specific legal rights, and you may have other rights that vary state to state. ITEM # GEN3000IOF Portable Gas Fuel Inverter Generator...
Page 5
• Keep generator dry and operate with dry hands. Do not use this generator in wet conditions (rain, snow, active sprinkler system, wet hands, etc.). • Do not touch bare wires or outlets (receptacles). • Do not allow children or non-qualified persons to operate this generator. ITEM # GEN3000IOF Portable Gas Fuel Inverter Generator...
Page 6
• Do not operate an excessive number of electrical devices in excess of the wattage capacity of this generator. • Do not turn on electrical devices until after they are connected to this generator. • Turn off all connected electrical devices before stopping this generator. ITEM # GEN3000IOF Portable Gas Fuel Inverter Generator...
Page 7
ITEM # GEN3000IOF Portable Gas Fuel Inverter Generator...
Page 8
In addition to the previously described safety information, familiarize yourself with all safety and hazard placards on this generator. ITEM # GEN3000IOF Portable Gas Fuel Inverter Generator...
The following item is supplied with this Generator. Verify that it is included. STOP! If there are missing items, call 1-866-460-9436, Monday - Friday, 8 AM - 4 PM Central Time for customer service. Item List: Spark plug wrench ITEM # GEN3000IOF Portable Gas Fuel Inverter Generator...
GENERATOR COMPONENTS Observe the locations and functions of the various components and controls of this generator. ITEM # GEN3000IOF Portable Gas Fuel Inverter Generator...
When the engine crankcase is full and almost overflowing, the oil level should reach the lower lip of the oil filling opening as shown in Figure 2. 4. Replace the oil filler/dipstick cap and close the oil access panel. Figure 1 – Unscrew the Dipstick Cap Figure 2 - Add Oil ITEM # GEN3000IOF Portable Gas Fuel Inverter Generator...
Grounding codes can vary by location. Contact a local electrician for information on grounding regulations for your area. Figure 3 The Grounding Terminal is located on the front of the generator. ITEM # GEN3000IOF Portable Gas Fuel Inverter Generator...
No. 12 AWG (American Wire Gauge) stranded copper wire. The other end of this grounding wire should be connected to a copper or brass grounding rod that is driven into the earth. Grounding codes can vary by location. Contact a local electrician for information on grounding regulations for your area. ITEM # GEN3000IOF Portable Gas Fuel Inverter Generator...
The choke is used to provide an enriched fuel mixture when starting a cold engine. It can be opened and closed by operating the choke rod manually. Pull the rod out toward CLOSED to enrich the mixture for cold starting Figure 4 The Recoil Start is located on the left side of the generator. ITEM # GEN3000IOF Portable Gas Fuel Inverter Generator...
120 Volt, single phase, 60 Hz loads to the 120 well water pump (1/3 HP) 1000 2000 Volt outlet. Connect 12 Volt, DC loads to the 12 Volt window air conditioner (10000 BTU) 1200 1800 outlet. window fan ITEM # GEN3000IOF Portable Gas Fuel Inverter Generator...
ECONOMY CONTROL SWITCH When the economy control switch is turned ON, the economy control unit control the engine speed according to the connected load. The results are better fuel connection and less noise. ITEM # GEN3000IOF Portable Gas Fuel Inverter Generator...
See specifications page in owner’s manual. Turning Off Generators while in Parallel Function 1. Disconnect or turn off item plugged into parallel receptacle. 2. Turn off both generators. 3. Carefully disconnect the parallel cables from both generators ITEM # GEN3000IOF Portable Gas Fuel Inverter Generator...
Never clean this generator with a bucket of water and/or a hose as water can get inside and cause a short circuit or corrosion. Never use gasoline to clean parts of this generator. ITEM # GEN3000IOF Portable Gas Fuel Inverter Generator...
TROUBLESHOOTING: IF THE GENERATOR WILL NOT START, DOUBLE CHECK THAT THE OIL LEVEL IS COMPLETELY FULL AND ALMOST OVERFLOWING. Figure 8A – REMOVE bolt and drain oil Figure 8B – Adding oil ITEM # GEN3000IOF Portable Gas Fuel Inverter Generator...
To store this generator for extended time, the fuel needs to be drained from the carburetor. To drain the gasoline from the carburetor turn the fuel valve to the “off” position while the engine is running. The generator will shut down when all the gasoline in the carburetor has been used. ITEM # GEN3000IOF Portable Gas Fuel Inverter Generator...
Empty the fuel tank. (See “Emptying the Fuel Tank” in the “Maintenance/Care” section.) 1 year or more Empty the fuel tank. (See “Emptying the Fuel Tank” in the “Maintenance/Care” section.) Disconnect the spark plug. ITEM # GEN3000IOF Portable Gas Fuel Inverter Generator...
Generator runs but does not support all Short in one of the connected devices. Disconnect any faulty or short-circuited connected electrical devices. electrical loads. Air filter is dirty. Clean or replace air filter. ITEM # GEN3000IOF Portable Gas Fuel Inverter Generator...
Page 23
ITEM # GEN3000IOF Portable Gas Fuel Inverter Generator...
(2) Any warranty part that is scheduled only for regular inspection in your Owner’s Manual is warranted for warranty period stated above. Any such part repaired or replaced under warranty will be warranted for the remaining warranty period. ITEM # GEN3000IOF Portable Gas Fuel Inverter Generator...
Page 39
(a) Purge valves (b) Carbon canister (c) canister Mounting Brackets (d) Fuel Cap (e) Fuel Tank (7) Miscellaneous items used in above systems including: (a) Switches (b) Hoses, belts connectors, and assemblies (8) Air injection system (a) Pulse valve 202007 ITEM # GEN3000IOF Portable Gas Fuel Inverter Generator...