Table of Contents
Advertisement
Quick Links
3500 Surge Watts / 3000 Running Watts
DUAL FUEL INVERTOR GENERATOR INSTRUCTION MANUAL
READ ALL INSTRUCTIONS AND WARNINGS BEFORE USING THIS PRODUCT.
This manual provides important information on proper operation & maintenance. Every effort has been
made to ensure the accuracy of this manual. These instructions are not meant to cover every possible
condition and situation that may occur. We reserve the right to change this product at any time without
prior notice.
IF THERE IS ANY QUESTION ABOUT A CONDITION BEING SAFE OR UNSAFE,
DO NOT OPERATE THIS PRODUCT!
Visit our website for Troubleshooting / Frequently Asked Questions
H A V E Q U E S T IO N S OR P R O B L E M S ? C O N T A C T C U S T O M E R S E R V IC E F IR S T
B E F O R E R E T U R N IN G T H IS P R O D U C T T O T H E R E T A IL E R
If you experience a problem or need parts for this product, visit our website http://www.buffalotools.com
or call our customer help line at 1-866-460-9436, Monday-Friday, 8 AM - 4 PM Central Time. A copy
of the sales receipt is required.
FOR CONSUMER USE ONLY – NOT FOR PROFESSIONAL USE.
KEEP THIS MANUAL, SALES RECEIPT & APPLICABLE WARRANTY FOR FUTURE
REFERENCE.
ITEM # GEN3500DFI
http://sportsmanseriesbrand.com/generators
Q
Advertisement
Table of Contents
Related Manuals for Sportsman GEN3500DFI
Summary of Contents for Sportsman GEN3500DFI
- Page 1 ITEM # GEN3500DFI 3500 Surge Watts / 3000 Running Watts DUAL FUEL INVERTOR GENERATOR INSTRUCTION MANUAL READ ALL INSTRUCTIONS AND WARNINGS BEFORE USING THIS PRODUCT. This manual provides important information on proper operation & maintenance. Every effort has been made to ensure the accuracy of this manual. These instructions are not meant to cover every possible condition and situation that may occur.
- Page 2 Rated Frequency (Hz) Phase Single DC Output Voltage (V) Circuit Breaker Amperage (A) Engine Engine Type 4-stroke single cylinder with forced air cooling system Ignition System Non-contact transistor (T.C.I.) Starting System Recoil Item # GEN3500DFI Portable Dual Fuel Invertor Generator...
-
Page 3: Table Of Contents
Changing Fuel Line ..............................22 Spark Plug Maintenance ............................22 Emptying The Fuel Tank ............................22 STORAGE/TRANSPORT PROCEDURES ........................23 TROUBLESHOOTING ..............................24 PARTS DIAGRAM ................................26 EMISSION CONTROL SYSTEM WARRANTY ......................... 31 Item # GEN3500DFI Portable Dual Fuel Invertor Generator... -
Page 4: Recognize Safety Symbols, Words And Labels
Parts replaced during warranty repairs will be considered as part of the original product and will have the same warranty period as the original product. This warranty gives you specific legal rights, and you may have other rights that vary state to state. Item # GEN3500DFI Portable Dual Fuel Invertor Generator... - Page 5 Avoid the use of extension cords if possible. If you choose to use them, be sure they are sized adequately to handle the flow of electricity. An undersized cord can overheat, short out and cause a fire. Item # GEN3500DFI Portable Dual Fuel Invertor Generator...
- Page 6 • Do not operate an excessive number of electrical devices in excess of the wattage capacity of this generator. • Do not turn on electrical devices until after they are connected to this generator. • Turn off all connected electrical devices before stopping this generator. Item # GEN3500DFI Portable Dual Fuel Invertor Generator...
- Page 7 Item # GEN3500DFI Portable Dual Fuel Invertor Generator...
- Page 8 In addition to the previously described safety information, familiarize yourself with all safety and hazard placards on this generator. Item # GEN3500DFI Portable Dual Fuel Invertor Generator...
-
Page 9: Package Contents
DC connector wires for charging 12 Volt automotive-type batteries Spark plug wrench 5 ft 9 inch Regulator Hose Kit (YOU MUST USE THE SUPPLIED REGULATOR FOR SAFE OPERATION) Funnel for adding Oil Item # GEN3500DFI Portable Dual Fuel Invertor Generator... -
Page 10: Components
12) 12 Volt DC Outlet 13) Grounding Terminal 14) 120 Volt RV Outlet 15) Smart Throttle 16) LP gas inlet 17) Parallel Ports A and B 18) USB Port 19) Alert Indicator Item # GEN3500DFI Portable Dual Fuel Invertor Generator... -
Page 11: Preparing The Generator For Use
When the engine crankcase is full and almost overflowing, the oil level should reach the lower lip of the oil filling opening as shown in Figure 2. 5. Replace the oil filler/dipstick cap and reattach the oil access panel. Figure 1 – Figure 1A Figure 1B Figure 1C Figure 2 - Add Oil Item # GEN3500DFI Portable Dual Fuel Invertor Generator... -
Page 12: Step 2 - Add Gasoline
If using LPG, first connect the regulator that was included with the generator to the Propane Fuel Tank, then connect the other end to the Gas Inlet. Make sure the LPG cylinder is vertical and securely positioned. Item # GEN3500DFI Portable Dual Fuel Invertor Generator... -
Page 13: Step 3 - Ground The Generator
(See “Changing/Adding Oil” in the “Maintenance/Care” section of this manual). 5. Confirm that the oil filler/dipstick cap is properly screwed in place when finished verifying the oil level. Item # GEN3500DFI Portable Dual Fuel Invertor Generator... -
Page 14: Step 2 - Verify Gas Level
No. 12 AWG (American Wire Gauge) stranded copper wire. The other end of this grounding wire should be connected to a copper or brass grounding rod that is driven into the earth. Grounding codes can vary by location. Contact a local electrician for information on grounding regulations for your area. Item # GEN3500DFI Portable Dual Fuel Invertor Generator... -
Page 15: Starting The Generator
It can be opened and closed by operating the choke rod manually. Choke OUT/OFF Choke IN/ON To Start To Run Figure 4 The Recoil Start is located on the left side of the generator. Item # GEN3500DFI Portable Dual Fuel Invertor Generator... -
Page 16: Using The Generator
120 Volt, single phase, 60 Hz loads to the 120 well water pump (1/3 HP) 1000 2000 Volt outlet. Connect 12 Volt, DC loads to the 12 Volt window air conditioner (10000 BTU) 1200 1800 outlet. window fan Item # GEN3500DFI Portable Dual Fuel Invertor Generator... -
Page 17: Dc Usage
“OFF” position, the engine runs at the rated speed of 4,100 r/min. Note: The Smart Throttle switch must be turned to the “OFF” position when using electronic devices that require a large starting current, such as a compressor. Item # GEN3500DFI Portable Dual Fuel Invertor Generator... -
Page 18: Ac Parallel Terminals
AC PARALLEL TERMINALS Located just above the RV Outlet, the generator’s Parallel Outlets enable a user to run two GEN3500DFI generator’s simultaneously. This operation requires special cables (sold separately). The parallel port terminals are used with a parallel kit (sold separately). It will allow two generators to be linked to increase output. The black and white wire connections are non-polarized and can be inserted into either the left or right ports. - Page 19 Fuel Switch to OFF position and let the engine continue to run until it burns off all remaining gasoline fuel in carburetor. Then turn the propane tank ON. If using propane and you want to switch to gasoline, turn the propane tank OFF and turn the gas Fuel Switch ON. Item # GEN3500DFI Portable Dual Fuel Invertor Generator...
-
Page 20: Stopping The Generator
Never clean this generator with a bucket of water and/or a hose as water can get inside and cause a short circuit or corrosion. Never use gasoline to clean parts of this generator. Item # GEN3500DFI Portable Dual Fuel Invertor Generator... -
Page 21: Checking The Oil Level
TROUBLESHOOTING: IF THE GENERATOR WILL NOT START, DOUBLE CHECK THAT THE OIL LEVEL IS COMPLETELY FULL AND ALMOST OVERFLOWING. Figure 8B – Adding oil Figure 8A – Use 12mm hex wrench to REMOVE bolt and drain oil Item # GEN3500DFI Portable Dual Fuel Invertor Generator... -
Page 22: Air Filter Maintenance
To store this generator for extended time, the fuel needs to be drained from the carburetor. To drain the gasoline from the carburetor turn the fuel valve to the “off” position while the engine is running. The generator will shut down when all the gasoline in the carburetor has been used. Item # GEN3500DFI Portable Dual Fuel Invertor Generator... -
Page 23: Storage/Transport Procedures
Empty the fuel tank. (See “Emptying the Fuel Tank” in the “Maintenance/Care” section.) 1 year or more Empty the fuel tank. (See “Emptying the Fuel Tank” in the “Maintenance/Care” section.) Disconnect the spark plug. Item # GEN3500DFI Portable Dual Fuel Invertor Generator... -
Page 24: Troubleshooting
Generator runs but does not support all Short in one of the connected devices. Disconnect any faulty or short-circuited connected electrical devices. electrical loads. Air filter is dirty. Clean or replace air filter. Item # GEN3500DFI Portable Dual Fuel Invertor Generator... - Page 25 Item # GEN3500DFI Portable Dual Fuel Invertor Generator...
-
Page 26: Parts Diagram
PARTS DIAGRAM Item # GEN3500DFI Portable Dual Fuel Invertor Generator... - Page 27 PARTS DIAGRAM Item # GEN3500DFI Portable Dual Fuel Invertor Generator...
- Page 28 PARTS DIAGRAM Valve Assembly Item # GEN3500DFI Portable Dual Fuel Invertor Generator...
- Page 29 PARTS DIAGRAM Item # GEN3500DFI Portable Dual Fuel Invertor Generator...
- Page 30 PARTS LIST Item # GEN3500DFI Portable Dual Fuel Invertor Generator...
-
Page 31: Emission Control System Warranty
Any such part repaired or replaced under warranty will be warranted for the remaining warranty period. (3) Any warranted part that is scheduled for replacement as required maintenance in your Owner’s Manual is warranted Item # GEN3500DFI Portable Dual Fuel Invertor Generator... - Page 32 (a) Purge valves (b) Carbon canister (c) canister Mounting Brackets (d) Fuel Cap (e) Fuel Tank (7) Miscellaneous items used in above systems including: (a) Switches (b) Hoses, belts connectors, and assemblies (8) Air injection system (a) Pulse valve 201806 Item # GEN3500DFI Portable Dual Fuel Invertor Generator...