Page 2
CONTROL PANEL. NO USER-SERVICABLE PARTS INSIDE. REPAIRS SHOULD BE DONE BY AUTHORIZED SERVICE PERSONNEL ONLY. NOTICE Using any part other than genuine Lang factory supplied parts relieves the manufacturer of all liability. Lang reserves the right to change specifications and product design without notice. Such revisions do not entitle the buyer to corresponding changes, improvements, additions or replacements for previously purchased equipment.
Exploded View & Parts List ..... 18-23 NOTICE Service on this or any other Lang appliance must be performed by qualified personnel only. Consult your Lang Authorized Service Agent Directory.
EQUIPMENT SPECIFICATIONS Height x Width x Depth Clearance from Weight Freight Model (Not including legs) combustible surface Actual Shipping Class 15.0" x 24.0" x 28.2" 243 lbs. 280 lbs. 381mm x 610mm x 717mm 110 kg 127 kg 15.0" x 36.0" x 28.2" 368 lbs.
EQUIPMENT DESCRIPTION Griddle Surface Gutter Grease Pan Feet IL1553 Section Temp. Dial Section Pilot Light Exterior Construction The griddle dimensions are 17” (43.18cm) High, 30” (76.20cm) Deep, and width is dependent on the actual model number. The Sides, Bottom, and Rear wall are constructed of double wall stainless steel, which allows closer installation to combustible surfaces.
UNPACKING Receiving the Griddle Upon receipt, check for freight damage, both visible and concealed. Visible damage should be noted on the freight bill at the time of delivery and signed by the carrier’s agent. Concealed loss or damage means it does not become apparent until the merchandise has been unpacked.
INSTALLATION IL1554 Std Leg Marine Bolt Down Leg Above: typical leg installation. Leg Installation There are four, 4” legs provided for 2, 3 and 4 foot griddles. 2.5” There are eight 4” legs provided for 5 and 6 foot griddles. The legs are shipped in the grease drawers IL1550 of the griddle.
Re-phasing the griddle is not 160T #1 1,3,5 2,4,6 chargeable to Lang Manufacturing 160T #2 Company as warranty. To convert 172T #1 1,3,5 2,4,6 to single-phase have a Lang 172T #2 1,3,5 2,4,6 Authorized Service Agent, follow this chart.
INITIAL START UP Pre-Power On Before starting the griddle for the first time, clean the griddle body and cooking surface. Use a mild soap and water solution, then rinse with clear water and dry. The griddle is shipped with a protective coating and craft paper covering the cooking surface. This MUST be removed before heating the cooking surface.
OPERATION General The suggested time and temperature chart (below) is provided as a guide for the products listed only. If different temperature settings are to be used, select one side of the griddle and operate at the lowest temperature. Adjoining sections should be set at progressively higher temperatures. Do not try to operate the end sections hot and the center sections cool.
Timer Operation (certain models) Start Up: • The current preset time is displayed when the power switch is turned on, and 3 beeps will sound. TIMER Timer Preset: • There are 3 programmable timer set points available. Press “+” “-“ button. •...
GRIDDLE CARE (CHROME SURFACES) (Chrome surface griddles are marked with “CHS” at the end of the model number designation on the nameplate.) It takes very little time and effort to keep this Industrial Chrome griddle surface sparkling clean and performing at top efficiency.
If an item on the list is followed by an asterisk (*), the work should be done by a factory authorized service representative. NOTICE: Service on this, or any other, LANG appliance must be performed by qualified personnel only. Consult your Lang Authorized Service Agent Directory or call the factory at 314-678-6315, or www.langworld.com For the service agent nearest you.
Model: Electric Thermostatic Griddle SK2397 Rev. - 8/15/08...
Page 19
PARTS LIST Rev. H 4/15/2016 Model No: 124T, 124TC, 124THE, 124TSS Accu-Temp Electric Griddle Fig No Part Number Description Application K9-XL-722-2 PLATE ASY 2’ ACU 124T K9-XL-722-21 PLATE ASY 2’ ACU 4.5 124T-480VSJ, 124TSS, 124TSS-480V K9-XL-722-211 PLATE ASSY 2’ ACU WITH 4.5 124T-PE, 124T-PE-480V K9-XL-722-24 PLATE ASY 2’...
Page 20
PARTS LIST Rev. H 4/15/2016 Model No: 136T, 136TC, 136THE Accu-Temp Electric Griddle Fig No Part Number Description Application K9-XL-0722-3 PLATE ASY 3’ ACU 136T, 136T-440VM, 136T-480V, 136TSS K9-XL-0722-31 PLATE ASSY 3’ ACCU 4.5” 136TSS K9-XL-0722-311 PLATE ASY 3’ ACT TALL B 136T-PE K9-XL-0722-W35 PLATE ASY 3’...
Page 21
PARTS LIST Rev. H 4/15/2016 Model No: 148T, 148TC, 148TSS, 148THS Accu-Temp Electric Griddle Fig No Part Number Description Application K9-XL-722-4 PLATE ASY 4’ ACU 148T K9-XL-722-41 PLATE ASY 4’ ACU 4.5 148T-SJ, 148TSS K9-XL-722-411 PLATE ASY 4’ ACU TALL B 148T-PE K9-XL-722-44 PLATE ASY 4’...
Page 22
PARTS LIST Rev. H 4/15/2016 Model No: 160T, 160TC, 160TSS Accu-Temp Electric Griddle Fig No Part Number Description Application K9-XL-0722-5 PLATE ASY 5’ ACU 160T K9-XL-0722-51 PLATE ASY 5’ ACU 4.5 160TSS K9-XL-722-511 PLATE ASY 5’ ACU TALL 160T-PE K9-XL-0724-54 PLATE ASY 5’...
Page 23
Fig No Part Number Description Application K9-XL-719-611 PLATE ASSY 6’ ACCU-REAR 172TCR K9-XL-720-61 TOP PLATE ASSY 6” LGR 172TBC K9-XL-0722-6 PLATE ASY 5’ ACU 172T K9-XL-0722-61 PLATE ASY 6’ ACU 4.5 172T-480VSJ, 172T-SJ, 172TSS K9-XL-0722-611 PLATE ASY 6’ ACU TALL...
Page 24
STAR INTERNATIONAL HOLDINGS INC. COMPANY Star - Holman - Lang - Wells - Bloomfield - Toastmaster 10 Sunnen Drive, St. Louis, MO 63143 U.S.A. (314) 678-6303 www.star-mfg.com...