Lubrication - IBEX TS51C Assembly And Quick Start Manual

Ibex TS51C Drum Mower Assembly Guide Copyright 2020 Ibex Equipment Co.
Figure 36 curtain straps secure to the guard frame

Lubrication

The correct oil for both the 90 degree gearbox and the drum unit reservoir is a gear oil near 90 weight (80W90
is commonly found in stores) that is rated for EP, or extreme pressure.
The 90 degree gearbox is filled to the bottom of the fill hole/fill level hole on the side.
The gearbox over the drums contains about 3 liters of oil. The oil is not easily visible, so use a straw or the like
to check the level. About 1-3/4 to 2 inches of oil is the correct level.
Do not overfill the gearboxes. Having the gearboxes too full of oil will cause overheating, foaming and
premature failure of the lubricating oil. If you are uncertain how to properly fill the gearbox with oil, please
contact your dealer for advice.
Verify that there is oil in the 2 gearboxes and lubricate all grease points. Some of the grease points will take
more grease than usual the first time they are lubricated due to filling up the air space between the bushings.
Figure 37 correct oil level in drum gearbox
Page | 17