Advertisement
OWNER'S MANUAL
INSTALLATION AND OPERATING INSTRUCTIONS
REPAIR PARTS LIST
60 CYCLE "BBN" SERIES
SHALLOW WELL JET PUMPS
T E
T E
R I
R I
A -
A -
S T
S T
T E
T E
R I
R I
A -
A -
S T
S T
1397 1194
1/3 - 3/4 H.P.
1 and 1-1/2 H.P.
1/3 & 1/2 HP
3/4 & 1 HP
MODELS
1/3 HP
1/2 HP
3/4 HP
1 HP
BBNB-30L
BBNC-30L
BBND-30L
BBNE-30L
STA-RITE INDUSTRIES, INC., DELAVAN, WISCONSIN 53115
S281 (Rev. 12/12/94)
©1994, Sta-Rite Industries, Inc. Printed In U.S.A.
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for STA-RITE BBN Series
Summary of Contents for STA-RITE BBN Series
- Page 1 1 and 1-1/2 H.P. 1/3 & 1/2 HP 3/4 & 1 HP MODELS 1/3 HP 1/2 HP 3/4 HP 1 HP BBNB-30L BBNC-30L BBND-30L BBNE-30L STA-RITE INDUSTRIES, INC., DELAVAN, WISCONSIN 53115 S281 (Rev. 12/12/94) ©1994, Sta-Rite Industries, Inc. Printed In U.S.A.
- Page 2 Cased Well Installation Add a tee to the driven pipe and run the pipe horizon- tally to the pump, making sure that it slopes gradually Connect a foot valve to the first length of suction pipe, up to the pump to avoid air traps. For long horizontal and lower the pipe into the well.
-
Page 3: Pump Installation
PUMP INSTALLATION PRIMING THE PUMP Install the pump as shown in Figures 1 & 2. It is impor- Never run pump dry. Running pump with- tant that a foot valve be used, or that a check valve be out water may cause pump to overheat, damaging seal installed in the horizontal line as near the pump as pos- and possibly causing burns to persons handling pump. - Page 4 ELECTRICAL Risk of serious or fatal electrical shock. Disconnect power at service panel be- Connect motor ground fore connecting pressure switch. wire before connecting power supply wires. Do not ground to a gas supply line. Turn off power before working on pump or motor.
-
Page 5: Pump Service
PUMP SERVICE Installation of Floating Seat (Figure 4C) 1. Clean polished surface of floating seat with clean Complete pump and piping system must be protected against below freezing temperature. cloth. Failure to do so could cause severe damage and voids 2. -
Page 6: Troubleshooting
2. Leak in suction side of pump. LIMITED WARRANTY Sta-Rite warrants to the original consumer of the products listed below, that they will be free from defects in material and workmanship for the Warranty Period from the date of original installation or manufacture as noted. -
Page 7: Service Kits
REPAIR PARTS LIST EXPLODED VIEW “BBN” SERIES - 1/3 THRU 1/2 HP 1391 1194 Figure 5 REPAIR PARTS LIST – “BBN” SERIES – 1/3 THRU 1/2 HP Model and Horsepower Part BBNB-30L BBNC-30L Description Used 1/3 HP 1/2 HP Motor - 1/3 HP, 60 Cycle - 115/230V AS100BHL –... - Page 8 REPAIR PARTS LIST EXPLODED VIEW “BBN” SERIES - 3/4 AND 1 HP 1392 1194 Figure 6 REPAIR PARTS LIST – “BBN” SERIES – 3/4 AND 1 HP Model and Horsepower Part BBND-30L BBNE-30L Description Used 3/4 HP 1 HP Motor - 3/4 HP, 60 Cycle - 115/230V A100ELL –...
Need help?
Do you have a question about the BBN Series and is the answer not in the manual?
Questions and answers