Maintenance Plan; Suction Plates And Sealing Lips; Filter - probst JUMBOMOBIL JM-VARIO-150-B Operating Instructions Manual

Maintenance and care
8.1.1

Maintenance Plan

Check the safety devices:
- vacuum gauge OK?
Inspect the filter
Electrical equipment OK? Cable glands tight?
Check the state of charge of the battery
Drain off condensation
Are the vacuum hoses in good condition (not brittle, not kinked, no
abrasion, no leaks)?
Are all connections and hose clamps tight.?
Are the brief operating instructions, the rating plate and the load
plate still attached to the device?
Are the Operating Instructions still available and are the users
familiar with them?
Inspect supporting elements (crane beam, etc.) for deformation,
wear and other damage.
Clean and inspect the suction plates (no cracks, sealing lip free of
damage, etc.) and replace as necessary
Is the inspection certificate up to date?
General condition of the device
Leak test
8.2

Suction Plates and Sealing Lips

Clean the sealing lips with glycerine once per week to remove any objects or dirt such as glue, wood chips, dust etc.
Damaged or worn sealing lips (cracks, holes, deformation) must be replaced immediately.
Use only cold solvent for cleaning the device. Do not use benzene or caustic liquids, since these will damage the hoses.
8.3

Filter

Inspect the paper filter at least once per week.
If it is very dirty, replace it.
Procedure:
●
Open the cover of the lifting device.
●
Loosen the hose clamp and take out the filter.
●
Install the new filter and secure it with the hose clamp.
●
Close the cover of the lifting device.
Interval
Daily Weekly Monthly Every 6 months
X
X
X
X X
X
X
X
X
36 / 38
Every 12 months
X
X
X
X
X
X
X
x
X
X
X
X