Table of Contents
Advertisement
Safety
JUMBO-BV-VARIO-B
V2
4.3
Instructions for Installation, Maintenance and Operating Personnel
The device must be installed and maintained by qualified personnel, mechanics and electricians.
!
Each person in your company involved in the installation, start-up, operation, maintenance, and repair
of the device must have read and understood the operating instructions and especially the chapter
"Safety" therein.
Your company must ensure by internal measures
!111
●
that the operators of the lifting device are properly trained,
●
that they have read and understood the operating instructions,
●
that the operating instructions will be available to them at any time.
The responsibilities for the tasks carried out with the device must be clearly organized and observed.
There must be no ambiguity regarding responsibilities.
4.4 Safety at work
●
The use of the vacuum lifting device is only permitted in proximity to the ground. Do not swing it
over peoples heads.
Danger
●
While using the vacuum lifting device is the stay of persons in the working area forbidden. Except it
is indispensable. Caused of the way of using the vacuum lifting device , e.g. if the device must be
leaded by hand.
Prohibition
●
While using the vacuum lifting device be sure that there are no persons in the working area. Danger
to Life!!
Prohibition
●
The operator is not allowed to leave the control unit as long as the vacuum lifting device loaded
with load. The load must always be in the range of vision of the operator.
●
The manual guiding of is only allowed for vacuum lifting devices with handles.
●
Do not use the vacuum lifting device to jerk seized set down load.
●
Do not lift any components off-centre, because that could fall down.
●
The vacuum lifting device should not be opened if the opening path of the gripping arm is blocked
Prohibition
by a resistance (e.g. other concrete blocks or the like)!
●
The capacity and the nominal width the vacuum lifting device are not allowed to cross over.
●
Avoid quick or jerky movements with the vacuum lifting device. E.g. caused through driving fast
over uneven grounds/site is forbidden. Because the gripping good could fall down.
Prohibition
4.5
Requirements for the Installation Location
●
The lifting vacuum lifting device may not be used in explosion-risk rooms or areas.
●
The ambient temperature may not exceed and 40 °C (if this temperature is exceeded, please
Prohibition
consult the manufacturer before using the device).
●
The vacuum lifting device must be connected to the electrical supply and the main switch of the
crane from which it is suspended.
Ensure, by means of internal instructions and regular inspections, that the area around the
workplace is kept clean and tidy at all times.
26/07/16
13 / 40
Advertisement
Chapters
Table of Contents
Troubleshooting
