Commissioning Procedure; Warning Note - Kemlan Horizon 700 Low Line Installation Instructions Manual

Installation Instructions Kemlan Three Sided Natural Draft

Commissioning Procedure

Installed correctly the burner should not emit any
fumes into the room. The following procedure should be
undertaken to test that the unit is operating correctly.
1 After unit has been operating for a short period a
smoke match, smoke tube, carbon dioxide analyser or
similar should be directed at the top opening of the
unit.
2 This procedure should be undertaken with the
following conditions in the room:
• Open or closed windows
• Operation of extraction/exhaust fans, range hoods
etc.
• Operation of other gas appliances
• Operation of optional appliance fan at any speed.
3 Should any spillage be detected the cause must be
rectified before allowing commissioning of unit.
4. Please test appliance operation before leaving.
25/02/2021
Electronic Ignition Gas Fireplaces
Ver. 1
User Instructions

1. WARNING NOTE:

operated this appliance will not leak gases.
Persistent fume emission must not be tolerated.
If fume emission does exist, then the following
immediate action should be taken.
A Open doors and windows to ventilate room.
B Turn the fire off.
C Check for flue blockage and clear if necessary.
D Do not attempt to relight the burner until the cause
of the emission has been identified and rectified.
Should assistance be required contact nearest
agent.
E The gas burner is designed to work in a Kemlan
Horizon electronic power flue ignition system.
Working correctly there will be no spillage. Unit
should cut out if not enough draw to ensure proper
functioning.
2 Initially the Kemlan coal fire may burn with a
slightly blue flame. After approximately 20 minutes
the fire will settle down and burn with a yellow
flame.
3 As with all gas fires your gas coal/pebble or log
fire should be regularly serviced. We
recommend once each year. Service information
for an authorised person to follow has been set
out in attached leaflet.
4 PLEASE NOTE: Only logs provided by Kemlan
should be used with this appliance.
5 DO NOT place articles on or against this
appliance.
DO NOT use or store flammable materials
near this appliance.
DO NOT spray aerosols in the vicinity of this
appliance whilst it is in operation.
DO NOT modify this appliance.
Primarily a decorative appliance not certified as
a space heater.
6 The appliance is a live fuel effect product
designed to operate with luminous flames and
may exhibit slight carbon deposition.
7. The guard is fitted to this appliance to reduce the
risk of fire or injury from burns and no part of it
should be permanently removed.
SERVICE - WARNING: ONLY TO BE SERVICED
BY AN AUTHORISED PERSON
Properly installed and
17