Table of Contents
Advertisement
Hydraulic Brake
! WARNING
Be sure to inspect the brakes before
each use. Always maintain brakes
according to the Maintenance Schedule.
Brake Fluid
NOTE: The brake fluid reservoir is
located below the front hood.
1. Check the brake fluid level in the
brake fluid reservoir. The fluid level
must be maintained between the
MAX and MIN level marks. If the
level in the reservoir is low, add DOT 4
brake fluid.
2. Press the brake pedal several times to
check for firmness.
3. If the pedal is not firm, the system
must be bled.
NOTE: Take the vehicle to an autho-
rized dealer for this service.
CAUTION
Be careful not to spill any fluid when
filling the brake fluid reservoir. Wipe
away spilled fluid immediately.
46
Brake Hoses
Carefully inspect the hydraulic brake hoses
for cracks or other damage. If found, take
the vehicle to an authorized dealer to have
the brake hoses replaced.
Brake Pads
The clearance between the brake pads
and brake discs is adjusted automatically
as the brake pads wear. The only mainte-
nance that is required is replacement of
the brake pads when they show excessive
wear. Check the thickness of each of the
brake pads as follows:
1. Remove a front wheel.
2. Measure the thickness of each brake
pad.
3. If the thickness of either brake pad
friction material is less than 1 mm
(0.039 in.), take the vehicle to an
XX115A
authorized dealer to have brake pads
replaced.
4. Install the wheel; then using a criss-
cross pattern, tighten the wheel nuts
incrementally to a final torque of
95 ft-lb.
XX022
Fuel Hoses
Inspect the hoses. Damage from aging may
not always be visible.
Protective Rubber Boots
The protective boots should be inspected
periodically according to the Mainte-
nance Schedule.
XX139
Advertisement
Table of Contents
