Clearances And Serviceability - FULTON Vantage VTG Series Installation And Operation Manual

INSTALLATION
MODEL
Specifi cations
Input Million BTU/Hr.
Fuel Cons. @ rated cap: (Nat. Gas)
Fuel Cons. @ rated cap.: (#2 Oil)
Output at AHRI Test Condition
Electrical Req. (Amps) 230V, 60Hz, 3 Phase
460V, 60Hz, 3 Phase
Water Content
Dry Weight
Operating Weight
Dimensions
A. Boiler Width
B. Overall Boiler Height
C. Overall Boiler Depth
D. Flue Outlet Diameter
E. Air Inlet Diameter
F. Water Inlet/Outlet Diameter
G. Min. Clearance to Ceiling
H. Overall Height (w/o blower)
* Alternate gas pressure arrangements may apply. Please verify gas pressure ratings for your boiler by viewing the boiler name plate.
** Typical 120 VAC controls allow for a +10% and a -15% voltage fl uctuation.
***Standard confi gurations. Alternate voltages available as an option; please consult factory.
Note: All dimensions are approximate and are subject to change without notice.
The use of propane may be allowable with concentrations up to 5% propylene, also referred to as HD5. Off -standard grades of propane are not permitted. Contact
factory for more information.

Clearances and Serviceability

Adhere to the following for clearances and serviceability:
1. All local and national codes (NFPA, ANSI, UL, CSA,
ASME) must be followed for proper clearances and
2-4
TABLE 1 - BOILER DIMENSIONS AND OPERATING REQUIREMENTS
VTG
2000 2000DF 2500 2500DF 3000
2000LE
2 2 2.5
kW 586 586 733
FT /Hr. 2,000 2,000 2,500 2,500
3
M /Hr 56.6 56.6 70.8 70.8
3
GPH NA 14.3 NA 14.3
LPH NA 54.1 NA 54.1
BHP 57 57 69
KCal/h 4.8 4.8 5.8
6.8 13.4 12.9
3.4 6.7 6.5
Gal 147 147 147
Liters 556.4 556.4 556.4 556.4
LB 3,800 3,800 3,800 3,800
KG 1724 1724 1724 1724
LB 5,100 5,100 5,100 5,100
KG 2314 2314 2314 2314
IN 30.5 30.5 30.5 33.6
CM 77.5 77.5 77.5 85.3
IN 64 64 76 72.8
CM 162.5 162.5 193 184.9
IN 108 122 108
CM 274.3 309.8 274.3 304.8
IN 10 10 10
CM 25.4 25.4 25.4 25.4
IN 8 10 10
CM 20.3 25.4 25.4 25.4
IN 4 4 4
CM 10.1 10.1 10.1
IN 24 24 24
CM 60.9 60.9 60.9 60.9
IN 68.1 64 64 68.1
CM 172.9 162.5 162.5 172.9
3000DF 3500 3500DF
3000LE
2.5 3 3 3.5 3.5
733 879 879 1026 1026
3,000 3,000 3,500 3,500
84.9 84.9 99.1 99.1
NA 21.4 NA 21.4
NA 81.0 NA 81.0
69 86 86 96 96
5.8 7.25 7.25 8.0 8.0
16.1 12.9 16.1 18.5 16.1
8.1 6.5 8.1 9.3 8.1
147 215 215 215 215
813.8 813.8 813.8 813.8
5,200 5,200 5,200 5,200
2359 2359 2359 2359
7,000 7,000 7,000 7,000
3175 3175 3175 3175
34.65 34.5 34.6 34.5
88.0 87.6 87.8 87.6
87 70.5 83.9 76.1
220.9 179.0 213.1 193.2
120 120 132 120 132
304.8 335.2 304.8 335.2
10 12 12 12 12
30.4 30.4 30.4 30.4
10 10 10 10 10
25.4 25.4 25.4 25.4
4 4 4 4 4
10.1 10.1 10.1 10.1 10.1
24 24 24 24 24
60.9 60.9 60.9 60.9
76.2 70.5 76.2 76.2
193.5 179.0 193.5 193.5
serviceability for your boiler or heater. Authorities
having jurisdiction should be consulted before
installations are made.
2. Appropriate front, back, side and top clearances must
be maintained (Figure 1). This will allow access around
the equipment to facilitate maintenance and a safe
SECTION 2
VTG-IOM-2013-0815
4000 4000DF 5000 5000DF 6000
4000LE
4 4 5 5 6
1172 1172 1465 1465 1758
4,000 4,000 5,000 4750 6,000
113.2 113.2 141.5 134.5 169.9
NA 28.6 NA 27.17 NA
NA 108.2 NA 102.8 NA
116 116 138 138 168
9.7 9.7 11.6 11.6 14.1
18.5 16.1 23 29.2 23
9.3 8.1 11 16.6 11
275 275 275 275 480
1041 1041 1041 1041 1817
5,800 5,800 5,800 5,800 9,950
2631 2631 2631 2631 4513
8,100 8,100 8,100 8,100 13,950
3674 3674 3674 3674 6327
40.5 40.5 40.5 40.5 50.5
102.8 102.8 102.8 102.8 128.2
87.6 78 87.6 79.5 90
222.5 198.1 222.5 201.9 228.6
124 136 136 136 155
314.9 345.4 345.4 345.4 393.7
14 14 14 14 14
35.5 35.5 35.5 35.5 35.5
12 12 12 12 12
30.4 30.4 30.4 30.4 30.4
6 6 6 6 6
15.2 15.2 15.2 15.2 15.2
24 24 24 24 24
60.9 60.9 60.9 60.9 60.9
78.5 78.0 79.5 79.5 90
199.3 198.1 201.9 201.9 228.6
© The Fulton Companies 2013
6000DF
6
1758
6,000
169.9
42.8
162.0
168
14.1
29.2
16.6
480
1817
10,800
4899
14,800
6713
50.5
128.2
90
228.6
155
393.7
14
35.5
12
30.4
6
15.2
24
60.9
90
228.6