Daily And Before Start Of Season - BALZER ELIMINATOR VACUUM TANK Series User Manual

CAUTION

Daily and Before Start of Season

Before Starting Tractor
1 . Check tires for damage and proper air pressure . Repair or replace as needed . Tire air pressure should be as listed in
Figure 28 below (for future reference check the box next to the tires on your machine) :
R1 - Lug
2 . Torque all lug nuts to 450 ft/lbs (before first use after purchase, daily for the first five [5] days, before first use of season,
and after replacing tires) .
3 . Inspect suspension system for damage . Repair or replace as needed .
4 . Inspect all hoses, connections, and reservoirs for leaks . Repair or replace as needed .
WARNING
5 . Check all oil and fluid reservoirs for proper levels . Fill to proper level with the oil or fluid approved for that system .
The oil level in the vacuum pump must not go below the minimum amount shown in the site gauge (Figure 29) . If it
does, damage to the pump will occur and total pump failure may occur . See "Vacuum Pump" on Page 37 for full
maintenance of the pump . If the oil reservoir on the slurry pump needs oil, fill until the oil is in the middle of the site
glass (Figure 30) .
Figure 29
Minimum Level
6 . Inspect all moving components for damage or excessive wear . Repair or replace as needed .
7 . Check braking system for damage or excessive wear . Repair or replace as needed .
28
o 28L X 26 R3 - 10 Bolt, 13 3/16" Bolt Circle
o 28LR26 R3 - 10 Bolt, 13 3/16" Bolt Circle
o 30 .5x32 R1 - 10 Bolt, 13 3/16" Bolt Circle
o 30 .5x32 R3 - 10 Bolt, 13 3/16" Bolt Circle
o 30 .5LR32 R1 - 10 Bolt, 13 3/16" Bolt Circle
o 30 .5LR32 R3 - 10 Bolt, 13 3/16" Bolt Circle
o 850/50 30 .5 - 10 Bolt, 13 3/16" Bolt Circle, 10 Ply
R3 - Diamond
o 900/60 32 R1 - 10 Bolt, 13 1/4" Bolt Circle
Before performing any maintenance on this machine,
turn off the tractor, remove the ignition key, and
relieve hydraulic pressure from the hydraulic systems
unless otherwise noted.
Figure 28
Tire Description
Using oils and fluids other than those approved and
specified for each system may result in damage to the
machine.
Eliminator Vacuum Tank (Tandem) User Manual
MAINTENANCE
Tire Pressure
26 (180 kPa)
54 (372 kPa)
33 (228 kPa)
33 (228 kPa)
52 (359 kPa)
52 (359 kPa)
37 (256 kPa)
35 (241 kPa)
Figure 30
Site Glass