Hydraulic System Safety; Pto Operation Safety - BALZER ELIMINATOR VACUUM TANK Series User Manual

SAFETY
Boom Safety (Continued)
Before moving this unit, make sure boom is properly resting in the boom saddle . Moving this unit with the boom not resting in
the boom saddle can result in damage to the unit, other equipment, or buildings . It could also create an unbalanced load which
could lead to the unit rolling onto its side .

Hydraulic System Safety

DO NOT smoke when working on hydraulic systems .
NEVER use your hand to search for hydraulic fluid leaks . Escaping fluid under pressure can be invisible and can penetrate the
skin causing serious injury and other health hazards . Escaping fluid can also be extremely hot causing severe burns .
Use a scrap piece of cardboard to check for leaks .
IF ANY FLUID IS INJECTED INTO YOUR SKIN, SEEK MEDICAL ATTENTION IMMEDIATELY! Notify medical staff that there
is an injection injury with hydraulic fluid . Injected fluid must be surgically removed by a doctor familiar with this type of injury
or gangrene may result .
DO NOT attempt to loosen or disconnect any lines, hoses, or fittings without first relieving hydraulic circuit pressure . Be careful
not to touch any hydraulic components recently in operation because they can be extremely hot .
ALWAYS replace hydraulic components with manufacturer recommended replacement parts . Improperly rated components
may result in system failure and/or injuries .
Contact your local Balzer dealer to order replacement parts .

PTO Operation Safety

WARNING
End Cone and Guard Chain
Tractor Master Shield
DANGER
Eliminator Vacuum Tank (Tandem) User Manual
PTO mounted drive shafts must only be used for their
intended purpose.
Figure 1
DO NOT operate PTO without all guards in place and
in safe operating condition.
Implement Safety Shield
End Cone and Guard Chain
Telescoping Section Sleeves
9