Husqvarna FS5000 D Operator's Manual page 29

4. Put the dipstick back fully into the oil tank.
5. Remove the dipstick.
6. Examine the oil level on the dipstick. Make sure that
the level of engine oil is between the marks on the
dipstick.
7. If the oil level is low, fill with engine oil and do a
check of the oil level again. Refer to
on page 42 for correct engine oil type.
To examine hoses and hose clamps
• Look for leakage on the hoses in the fuel system, the
hydraulic system and the cooling system.
• Examine the hoses for wear and damage, especially
where the hoses rub against other hoses or parts of
the product.
• Replace damaged hoses.
• Tighten loose hose clamps.
To clean the outer air filter
WARNING: Use approved respiratory
protection when you clean or replace the air
filter. Discard used air filters correctly. The
dust in the air filter is dangerous to your
health.
WARNING: Do not clean the air filter with
compressed air. This causes damage to the
air filter and the risk increases that you
breathe the dangerous dust.
It is not necessary to clean the inner air filter.
1. Examine the air filter indicator (A). If the air filter
indicator is red, it is necessary to clean the outer air
filter.
2. Open the 3 clamps of the air filter housing and
remove the air filter housing.
1143 - 002 - 08.07.2019
3. Remove the air filter.
4. Tap the air filter against a hard surface or use a
5. Replace damaged gaskets.
6. Examine the air filter hose and the hose clamps.
Technical data
7. Install the outer air filter.
8. Install the air filter housing and close the 3 clamps of
To drain water from the gearbox
1. Turn the water drain valve on the gearbox
A
2. Turn the water drain valve on the gearbox clockwise
vacuum cleaner to remove the particles.
CAUTION: Do not let the nozzle of the
vacuum cleaner touch the surface of the
air filter. Keep a small distance. The
sensitive surface of the air filter becomes
damaged if objects touch it.
a) Replace damaged parts.
b) Tighten loose clamps.
the air filter housing.
Note: If the 3 clamps of the air filter housing cannot
be closed, the outer air filter is not correctly installed.
CAUTION: Always replace a damaged air
filter, or the dust will go into the engine and
cause engine damage. Damage to the
engine because of a damaged air filter voids
the warranty.
CAUTION: Water in the gearbox can cause
corrosion and freeze damages.
counterclockwise to open.
to close.
29