QUICK START GUIDE Phase 1 - Assembly q 1.1 Setup............................... 3 - 5 q 1.2 Workbench Assembly........................5 - 8 Phase 2 - Installation q 2.1 Attach Wall Brackets To The End Panels..................q 2.2 Mark Holes For Plus Nuts....................... q 2.3 Attach Plus Nut..........................
Page 3
Shelf Tray Plywood 70-810 Hardwood Top 70-816 Side Panel Bracket 70-817 Steel Striker Plate 70-818 Straight Backsplash 96-4802 Install Fastener Kit 94-4801 Assembly Fastener Kit S3-WA48-1 Installation Guide | REV. A2 | Page 3 For technical support, contact us at 1-800-565-5321...
Page 4
( QTY = g ap beTween floor and end panel #94-132 5/16" Plusnut Spacer 4× # 98-157 0.375" ID, × 1.0" OD × 0.25" LONG NYLON S3-WA48-1 Installation Guide | REV. A2 | Page 4 For technical support, contact us at 1-800-565-5321...
Page 5
60 - 13.875 × 48 TOOLS q Cordless Impact q 3/8" Driver Bit 40 - 738 HARDWARE USED 8× 19 - 3/4" #92-102 Screw #14 × 1" S3-WA48-1 Installation Guide | REV. A2 | Page 5 For technical support, contact us at 1-800-565-5321...
Cordless Impact q 1/2" Socket BRACKET HARDWARE USED 4× hand tighten the bolts #90-114 Hex Bolt 1/4" × 1" #98-106 Flat Washer #94-112 Serrated Nut S3-WA48-1 Installation Guide | REV. A2 | Page 9 For technical support, contact us at 1-800-565-5321...
Page 10
Mark 2 holes of each end panel on the vehicle floor. NOTE: If you are using Ranger floor, please go to page TOOLS q Marker MARK S3-WA48-1 Installation Guide | REV. A2 | Page 10 For technical support, contact us at 1-800-565-5321...
Page 11
1/2" Drill Bit w/ Drill Collar ( Set at 1/2" ) q Plus Nut Tool ( 5/16" ) HARDWARE USED 8× #94-132 Plus Nut DRILL COLLAR 1/2" ) seT aT S3-WA48-1 Installation Guide | REV. A2 | Page 11 For technical support, contact us at 1-800-565-5321...
Page 12
1/2" socket until the plusnut locks, then remove the bolt by turning the impact in reverse. FORWARD REVERSE S3-WA48-1 Installation Guide | REV. A2 | Page 12 For technical support, contact us at 1-800-565-5321...
Page 13
#94-132 5/16" Plusnut ips When to use spacer most vehicle use spacer When not over ribs W/ Spacer W/O Spacer S3-WA48-1 Installation Guide | REV. A2 | Page 13 For technical support, contact us at 1-800-565-5321...
Page 17
“You have successfully installed your Workbench Thank you for doing business with us.” cs@rangerdesign.com For any feedback or suggestions you may have, please contact: S3-WA48-1 Installation Guide | REV. A2 | Page 17 For technical support, contact us at 1-800-565-5321...