Jandy Versa-Plumb CL Series Installation And Operation Manual
Cartridge pool filters
Hide thumbs
Also See for Versa-Plumb CL Series:
- Installation and operation manual (20 pages) ,
- Installation and operation manual (20 pages)
Table of Contents
Advertisement
Installation and Operation Data
Installation and
Operation Manual
®
Jandy
Cartridge
Pool Filters
CL and CV Versa-Plumb
Series Filters
FOR YOUR SAFETY - This product must be installed and serviced by a professional pool/
spa service technician. The procedures in this manual must be followed exactly. Improper
lid to be blown off, possibly causing death, serious injury or property damage. Improper
installation and/or operation will void the warranty.
Before installing this product, read and follow all warning notices and instructions that
property damage, serious injury, or death.
™
™
b
WARNING
Advertisement
Table of Contents
Related Manuals for Jandy Versa-Plumb CL Series
Summary of Contents for Jandy Versa-Plumb CL Series
- Page 1 Installation and Operation Data Installation and Operation Manual ® Jandy Cartridge Pool Filters ™ ™ CL and CV Versa-Plumb Series Filters WARNING FOR YOUR SAFETY - This product must be installed and serviced by a professional pool/ spa service technician. The procedures in this manual must be followed exactly. Improper lid to be blown off, possibly causing death, serious injury or property damage.
-
Page 3: Table Of Contents
Filter Preparation ......6 Filter Plumbing ......7 Section 10. Head Loss Curves ......16 Clamp Installation ......10 ® 10.1 Jandy CL and CV Cartridge Filter Design Head Loss Curves ..... 16 Section 4. Start-Up and Operation ...... 10 Warranty ............20 Section 5. -
Page 4: Section 1. Safety Information
BE SURE TO COMPLY WITH THE FOLLOWING SAFETY INSTRUCTIONS: installed and secured before testing. RELEASE ALL AIR in the system before testing. Notice: These parameters apply to Jandy equipment only. For non-Jandy equipment, consult equipment manufacturer. 1.2 General Safety Instructions ATTENTION INSTALLER: This manual contains important information about the installation, operation and safe use of this product. -
Page 5: Section 2. General Information
Barrel unions are 2.1 Introduction WARNING This manual contains information for the proper instal- lation and operation of the Jandy ® CL and CV Series psi. Never subject the filter to operating pressure Cartridge Filters. Procedures in this manual must be can cause the lid to be blown off, which can result in followed exactly. -
Page 6: Section 3. Installation Instructions
NOTE Anchor screws and washers for securing the anchor bracket to the equipment pad are not permit a visual inspection of the clamp ring (see kit. Jandy recommends that a ¼" x 2¼" long stainless steel Tapcon ® concrete screw and Fig. -
Page 7: Filter Plumbing
Cartridge Pool Filters - CL and CV Series Filters Page 7 #12x1” Stainless Steel Pan Filter Base Head Screws (Qty 2) #12x1” Pan Head Drill Two 3/32” Holes Stainless Steel Through Filter Base Mounting Tab Screw (Qty 8) Mounting Bracket 1/4”... - Page 8 Cartridge Pool Filters - CL and CV Series Filters Page 8 From Outlet Port Jandy Heater Spa Make Up To Inlet Port Jandy Jandy Pump Waterfall Check Jandy Filter Valve From Pool Drain Spa Return Pool Return Spa Suction From Pool Skimmer Figure 5.
- Page 9 NOTE The SHP pump shown in Figure 8 is for reference any unions. Assemble the unions dry and hand only. The Jandy sweep elbow also works with the tighten. See Figure 6. MHP and PHP series pumps. using a Jandy universal union. The plumbing must contain a ball valve as shown in Figure 6.
-
Page 10: Clamp Installation
Cartridge Pool Filters - CL and CV Series Filters Page 10 Check that the tank clamp is correctly seated and tight (See Figs. 9 and 10). WARNING Clamp Ring NEVER start pump while standing the pump while there is pressurized air in the system can cause the filter lid to be blown off, which can cause death, serious personal injury or property... -
Page 11: Section 5. Filter Disassembly And Assembly
Cartridge Pool Filters - CL and CV Series Filters Page 11 IMPORTANT: Completely open air release valve "T" Nut Threaded Tightening Nut w/ from inside the tank and system. Shoulder Remove the drain plug located at the bottom of the Tightening Clamp Nut w/... -
Page 12: Pressure Gauge
6.2 Pressure Gauge water leaks at least once a week. Keep the pressure gauge in good working order. If you suspect a problem with the gauge, Jandy CAUTION Maintain your pressure gauge in good working order. The pressure gauge is the primary indicator of how the filter is operating. -
Page 13: Section 8. Troubleshooting
Cartridge Pool Filters - CL and CV Series Filters Page 13 Section 8. Troubleshooting For a list of common problems and solutions see the Troubleshooting Guide below. system. For technical service call 707.776.8200, ext. 260. Table 2. Troubleshooting Guide Fault Symptom Possible Problems Solutions Water is not clear. -
Page 14: Section 9. Parts List And Exploded View
Cartridge Pool Filters - CL and CV Series Filters Page 14 Section 9. Parts List and Exploded View ® 9.1 Jandy CL and CV Cartridge Filter Parts List Description Model No. Part No. Handle Assembly w/ hardware (set of 2) -
Page 15: Jandy ® Cl And Cv Filters Exploded View
Cartridge Pool Filters - CL and CV Series Filters Page 15 ® 9.2 Jandy CL and CV Filters Exploded View CL Filter CV Filter 22,18 18,21 15,21 15,22... -
Page 16: Section 10. Head Loss Curves
Cartridge Pool Filters - CL and CV Series Filters Page 16 Section 10. Head Loss Curves ® 10.1 Jandy CL and CV Cartridge Filter Design Head Loss Curves CL340 CV340 CL460 CV460 CL580 CV580 Design Design Head Pressure Loss Drop... - Page 17 Cartridge Pool Filters - CL and CV Series Filters Page 17 Notes...
- Page 18 Cartridge Pool Filters - CL and CV Series Filters Page 18 Notes...
- Page 19 Cartridge Pool Filters - CL and CV Series Filters Page 19 Notes...
-
Page 20: Warranty
DE grids, or cartridge elements; or damage caused by running the pump with insufficient quantities of water. LIMITATION OF LIABILITY: This is the only warranty given by Jandy Pool Products, Inc. No one is authorized to make any other warranties on behalf of Jandy Pool Products, Inc. THIS WARRANTY IS IN LIEU OF ALL OTHER WARRANTIES, EXPRESSED OR IMPLIED, INCLUDING BUT NOT LIMITED TO ANY IMPLIED WARRANTIES OF FITNESS FOR A PARTICULAR PURPOSE AND MERCHANTABILITY.