Service - Southbend 4365A Owner's Manual

S
ERVICE
ADJUSTMENTS AND SERVICE WORK MAY BE PERFORMED ONLY BY A QUALIFIED TECHNICIAN WHO IS
EXPERIENCED IN, AND KNOWLEDGEABLE WITH, THE OPERATION OF COMMERCIAL COOKING
EQUIPMENT. TO ASSURE YOUR CONFIDENCE, CONTACT YOUR AUTHORIZED SERVICE AGENCY FOR
RELIABLE SERVICE, DEPENDABLE ADVICE OR OTHER ASSISTANCE, AND FOR GENUINE FACTORY
PARTS.
INSTALLATION OF OTHER THAN GENUINE SOUTHBEND PARTS WILL VOID THE WARRANTY ON THIS
EQUIPMENT.
The serial plate are located on the right side of the range (see Figure 1 on page 3).
Replacement parts (including parts not listed in this manual) may be ordered either through a Southbend Authorized
Parts Distributor or a Southbend Authorized Service Agency.
When ordering parts, please supply the Model Number, Serial Number, Part Number, and Part Description.
In case of problems in operation at initial installation, check type of gas and manifold pressure and compare with
information listed on the serial plate.
This section contains troubleshooting flowcharts, procedures, and electric schematics to assist a qualified service
technician in the servicing of a Southbend Ultimate Restaurant Range.
T
ROUBLESHOOTING
Find the symptom below that corresponds to the malfunction, then turn to the corresponding page. Follow the
flowchart on that page until the problem is solved.
Troubleshooting Flowchart, Procedure, or Wiring Diagram
Troubleshooting Open-Top Burners
Troubleshooting Base Oven
Troubleshooting Convection-Oven Blower
Adjustment of Gas Pressure Regulator
Adjustment of Open-Top Pilots
Adjustment of Open-Top Burners
Adjustment of Oven Standing Pilot
Adjustment of Oven Burner
Adjustment of Charbroiler, Standard-Griddle, and Uniform Hot-Top Burners and Pilots
Calibration of Oven Thermostat
Adjustment of Thermostatic Griddle Bypass Flame Level
Calibration of Thermostatic Griddle Thermostat
Conversion from One Type of Gas to Another
Wiring Diagram for Gas Oven
Wiring Diagram for Infrared Broiler in Gas Oven Cavity
Wiring Diagram for Electric Standard Oven
Wiring Diagram for Electric Convection Oven
O '
WNER S
F , P
LOWCHARTS ROCEDURES
M 1190820 REV 3 (11/10)
ANUAL
WARNING
NOTICE
, W
AND IRING
D
IAGRAMS
Page
22
23
24
26
27
27
27
27
27
28
28
28
29
30
31
32
33
P 21 48
AGE OF