Table Of Contents; Safety Instructions - Merlin WeatherDrive MR550EVO Installation And Operating Instructions Manual

START BY READING THESE IMPORTANT SAFETY INSTRUCTIONS
WARNING
• Failure to comply with the following instructions may result in serious personal injury or property damage.
• Read and follow all instructions carefully.
• The garage door opener is designed and tested to offer safe service provided it is installed and
operated in strict accordance with the instructions in this manual.
These safety alert symbols mean WARNING : A possible risk to personal safety or
property damage exists.
Keep garage door balanced. Do not let the
garage door opener compensate for a binding or
sticking garage door. Sticking, binding or
unbalanced doors must be repaired before
installing this opener.
Do not wear rings, watches or loose clothing
while installing or servicing a garage door opener.
Wear gloves and suitable protective clothing
where appropriate.
Frequently examine the door installation, in
particular cable, springs and mountings for signs
of wear, damage or imbalance. Do not use if
repair or adjustment is needed since springs and
hardware are under extreme tension and a fault
can cause serious personal injury.
To avoid serious
entanglement, remove all ropes, chains and
locks connected to the garage door before
installing the door opener.
Installation and wiring must be in compliance
with your local building and electrical codes.
The safety reverse system test is very
important. Your garage door MUST reverse on
contact with a 40 mm obstacle placed on the floor.
Failure to properly adjust the opener may result in
serious personal injury from a closing garage
door. Repeat the test once a month and make
any necessary adjustments.
This appliance is not intended for use by persons
(including children) with reduced physical, sensory
or mental capablities, or lack of experience and
knowledge, unless they have been given
supervision or instruction concerning use of the
appliance by a person responsible for their safety
Automatic Drive - Keep away from the area of
the door as it may operate unexpectedly.
NOTE: If your garage has no service entrance door, a CM1702 or DMK1 outside quick release must be installed.
This accessory allows manual operation of the garage door from outside in case of power failure.
CONTENTS
SAFETY INSTRUCTIONS . . . . . . 3
CARTON INVENTORY . . . . . . . . . .4
TOOLS REQUIRED . . . . . . . . . . . .4
DOOR REQUIREMENTS . . . . . . . .4
PREPARE & TEST THE DOOR . . .5
CONTROL PANEL . . . . . . . . . . . . . .6
MANUAL RELEASE KEY
LOCKABLE . . . . . . . . . . . . . . . . . . .7
PINNING THE DOOR . . . . . . . . . . .8
INSTALLATION PROCEDURE . . . .9
ADJUSTMENT & TESTING . . .10-11
INSTALL THE PROTECTOR
SYSTEM . . . . . . . . . . . . . . . . . . . .12
INSTALLING WIRELESS WALL
BUTTON . . . . . . . . . . . . . . . . . . . .13
personal injury from
PAGE
3
The opener must not be used on a wicket
door (door within a door).
The Protector System
installations where the closing force as
measured on the bottom of the door is over
400 N (40 kgf). Excessive force will interfere
with the proper operation of the safety reverse
system or damage the garage door.
After installation, ensure that the parts of
the door do not extend over public
footpaths or roads.
Install the wireless wall control (or any
additional wall control) in a location where
the garage door is visible away from
moving parts, at a height of at least 1.5 m
and out of the reach of children. Do not
allow children to operate push button(s) or
transmitter(s). Serious personal injury from a
closing garage door may result from misuse of
the opener.
Permanently fasten the Warning Labels in
prominent places, adjacent to wall controls
and manual release mechanisms as a
reminder of safe operating procedures.
Activate opener only when the door is in
full view, free of obstructions and the
opener is properly adjusted. No one should
enter or leave the garage while the door is
in motion.
Do not allow children to play near the door,
or with door controls.
If the supply cord is damaged, it must be replaced
by the manufacturer, its service agent or similarly
.
qualified persons in order to avoid hazard.
Disconnect electric power to the garage
door opener before making repairs or
removing covers.
KEEP THESE INSTRUCTIONS
TRAVEL SPEED . . . . . . . . . . . . . .13
STANDBY MODE . . . . . . . . . . . . .14
AUDIBLE BEEP . . . . . . . . . . . . . . .14
CONTROL PANEL E-LOCK . . . . .15
PARTIAL OPENING . . . . . . . . . . .15
WIRELESS PROGRAMMING . . . .16
OPERATING YOUR OPENER . . .17
MAINTAINING YOUR OPENER . . 17
CARE OF YOUR OPENER . . . . . 17
SPECIFICATION . . . . . . . . . . . . . .17
ACCESSORIES & WIRING . . . . . .18
SPARE PARTS . . . . . . . . . . . . . . .19
TROUBLESHOOTING . . . . . . . . .20
DIAGNOSTIC CHART . . . . . . . . . .21
WARRANTY . . . . . . . . . . . . . . . . .22
TM must be used for all