Fuel System; General; Chapter 5 - Monterey M3 Owner's Manual

Chapter 5:

FUEL SYSTEM

5.1 General

The gasoline fuel system used in Monterey boats
is designed to meet or exceed the requirements of
the U.S. Coast Guard, the Boating Industry Asso-
ciation, and The American Boat and Yacht Council
in effect at the time of manufacture.
All gasoline fuel systems have been factory in-
spected and pressure tested in accordance with
regulations in effect at the time of manufacture.
This inspection assures that the system is air tight,
leak proof and safe. It is the responsibility of the
purchaser to maintain it in that condition. Make
frequent inspections to assure that no deteriora-
tion or loosening of connections is resulting from
vibration.
DANGER
DO NOT LET THE ODOR OF GASOLINE GO UNCHECKED. ANY
ODOR OF GASOLINE MUST BE IMMEDIATELY INVESTIGATED
AND STEPS TAKEN TO PROTECT THE BOAT AND ITS
OCCUPANTS UNTIL THE PROBLEM IS CORRECTED. IF THE
ODOR OF GASOLINE IS NOTICED, SHUT OFF ALL ENGINE
AND ELECTRICAL EQUIPMENT. INVESTIGATE AND CORRECT
THE SITUATION IMMEDIATELY. HAVE ALL PASSENGERS
PUT ON PERSONAL FLOTATION DEVICES AND KEEP A FIRE
EXTINGUISHER READY UNTIL THE SITUATION IS RESOLVED.
Fuel Withdrawal Tube
The fuel withdrawal tube is positioned in the fuel
tank to achieve optimum fuel usage, fuel line rout-
ing, etc. At certain speeds and hull trim angles,
the fuel supply at the withdrawal tank location can
increase or decrease accordingly. Be extremely
careful when attempting to operate the boat when
low on fuel. Though some fuel may be in the tank,
the relative trim angle of the boat may cause the
fuel to flow away from the withdrawal.
Fuel Gauge
This indicates the amount of fuel in the tank. Due
to the mechanical nature of the fuel sender, varia-
tions in readings during various speeds of opera-
tion may occur. This system is merely a relative
indication of the available fuel supply and not a
calibrated instrument.
Typical Keyless Fuel Fill
Fuel Fill
A "keyless" fuel fill is located on the port gunnel
that is marked "GAS." The fuel fill is opened by
lifting the tab and turning the cap counter clock-
wise until it can be removed. After fueling, install
the fuel cap and tighten.
Be sure to use the proper type and grade fuel.
Refer to the engine owner's manual for additional
information.
Notice:
Do not overtighten the fuel cap.
is overtightened, the O-ring seal could be
damaged allowing water to contaminate the
fuel system.
WARNING
DO NOT CONFUSE FUEL FILL DECK PLATES WITH THE WATER
OR WASTE FILL DECK PLATES. THESE PLATES ARE ALSO
LABELED ACCORDINGLY. IF GASOLINE OR DIESEL FUEL IS
ACCIDENTALLY PUMPED INTO THE WATER OR WASTE TANK,
DO NOT ATTEMPT TO PUMP IT OUT YOURSELF. WATER AND
WASTE PUMPS ARE NOT DESIGNED TO PUMP FUEL AND A FIRE
OR EXPLOSION COULD RESULT. CONTACT YOUR DEALER
OR THE MONTEREY CUSTOMER SERVICE DEPARTMENT
FOR ASSISTANCE IN HAVING THE FUEL PROFESSIONALLY
REMOVED.
MONTEREY
BOATS
If the cap
55