BWT AQA Perla Installation And Operating Manual

Hide thumbs Also See for AQA Perla:

Installation and operating manual (136 pages)

Instructions for assembly and use (68 pages)

Installation and operating manual (84 pages)

Table Of Contents

See also: Installation and Operating Manual

Changes reserved!

Installation and operating manual

Duplex water softening unit

Table of Contents

Need help?

Do you have a question about the AQA Perla and is the answer not in the manual?

Questions and answers

Summary of Contents for BWT AQA Perla

Page 1 Installation and operating manual Installation and operating manual Installation and operating manual Installation and operating manual Installation and operating manual Duplex water softening unit Duplex water softening unit Duplex water softening unit Duplex water softening unit Duplex water softening unit Changes reserved! Changes reserved! Changes reserved!
Page 2: Table Of Contents
BWT unit. purchasing a BWT unit. purchasing a BWT unit. purchasing a BWT unit. purchasing a BWT unit.
Page 3 ety Instr ety Instr uctions uctions Safety Instr ety Instr ety Instructions uctions uctions GB GB GB GB The power supply unit in the controller is con- structed according to DIN 60335. The complete power supply unit must be replaced in event of Danger damage to the mains cable.
Page 4: Intended Use
Intended Use Intended Use Intended Use Intended Use AQA Perla is intended for the softening or partial softening of drinking and service water (according to relevant standards and rulings, DIN 1988, part 2 and 7 and regulations of the DVGW [German association of gas and water specialists]).
Page 5: Function
Installation Requirements Installation Requirements GB GB GB GB AQA Perla is a duplex softening unit that functions Observe all applicable installation regulations, general in accordance with the ion exchange principle. The guidelines, hygiene requirements, and technical speci- unit is run with columns continually changing at fications.
Page 6 BWT does not assume responsibility if the If the softened water is intended for human consump- unit fails or if the capacity becomes deficient...
Page 7: Installation
Installation Diagram Installation Diagram Installation Diagram Installation Diagram Installation Diagram Pressure GB GB GB GB reducer Hydro Filter stop Hydrostop Pressure reducer Metering unit optional but may be required, depending on operating conditions Floor drain Installation Installation Installation Installation Installation Multiblock A Multiblock A Multiblock A...
Page 8 Insert a flushing water hose (11 11) into the Y-piece. GB GB GB GB Route the flushing water hose (11 11) at an incline to the sewage system connection (drain) and se- cure the end with the fixing material supplied to prevent it flapping about when under pressure.
Page 9 Oper Oper Operation and control unit displa ation and control unit displa ation and control unit displays ation and control unit displa ys ys ys ys Oper Oper ation and control unit displa GB GB GB GB Confirms Confirms Moves cursor, Moves cursor, Confirms Confirms...
Page 10 Star Star t-Up t-Up Star Start-Up Star t-Up t-Up GB GB GB GB Check that the unit has been properly installed (according to DIN 1988, part 4). Measure and note the hardness of the drinking water upstream of the softener with AQUATEST. 2 2 2 2 2 Preparing the brine Preparing the brine...
Page 11 Insert mains plug. GB GB GB GB Water supply must remain closed. The display shows the Start screen Start screen Start screen Start screen Start screen with 0 l/h 00 : 00 : 01 the version number. Allow basic fixing to finish (approx. Allow basic fixing to finish (approx.
Page 12: Initial Start-Up
Star Star Star Star Start-up flush t-up flush t-up flush t-up flush t-up flush Time GB GB GB GB Slowly turn on the water supply (multiblock). Σ Current softened water supply Press the Browse Browse Browse Browse button. Browse Set the cursor to Manual Manual Manual Manual.
Page 13 °dH °dH °dH drinking water. Hardness of blended water Enter desired hardness of the blended water (BWT recommendation 4°-8°dH). Enter hardness of water Enter hardness of water Enter hardness of water Enter hardness of water Enter hardness of water Move the arrow horizontally to the required field.
Page 14 AQUATEST hardness tester. Adjust with the blending valve (V V V V V ) until the desired value (BWT recommendation 4°- 8°dH) is reached. The German drinking water regulations stipulate...
Page 15: Checklist
Checklist Checklist Checklist Checklist Checklist for proper installation by a qualified fitter GB GB GB GB Y Y Y Y Y ou can use this list to ou can use this list to ou can use this list to ou can use this list to ou can use this list to check your work again check your work again...
Page 16: Operation
Operation Operation Operation Operation Operation Please note that there is a separate GB GB GB GB manual for the multiblock module and connection set DN 32/32. Manually start regeneration Manually start regeneration Manually start regeneration Manually start regeneration Manually start regeneration Browse Browse Press the Browse...
Page 17 Fill regenerative Fill regenerative Fill regenerative Fill regenerative Fill regenerative GB GB GB GB Refill the regenerative as soon as the sieve base (5 5 5 5 5 ) becomes visible or when lo lo lo lo low-salt w-salt w-salt w-salt w-salt is indicated on the display.
Page 18 Changing the national Changing the national Changing the national Changing the national Changing the national language language language GB GB GB GB language language Only change this setting if another lan- guage is required. Press the Browse Browse Browse Browse button. Browse Set the cursor to ABC..
Page 19: Checks
Checks Checks Operator Responsibilities Operator Responsibilities Checks Checks Checks Operator Responsibilities Operator Responsibilities Operator Responsibilities The operator must perform the following checks The operator must perform the following checks The operator must perform the following checks The operator must perform the following checks The operator must perform the following checks You have purchased a durable and service-friendly GB GB...
Page 20: Troubleshooting
T T T T T roub roub roub leshooting leshooting roub roubleshooting leshooting leshooting GB GB GB GB F F F F F ault ault ault ault ault Cause Cause Cause Cause Cause Action Action Action Action Action Unit not supplying softened or No regenerative in the storage Refill regenerative and start blended water.
Page 21: Standards And Legal Regulations Standards And Legal Regulations
Standards and Legal Regulations Standards and Legal Regulations Standards and Legal Regulations Standards and Legal Regulations Standards and Legal Regulations In the newest version In the newest version In the newest version In the newest version In the newest version GB GB GB GB The following standards and legal regulations must be observed depending on the intended use:...
Page 22: Technical Specifications
T T T T T echnical Specifications echnical Specifications echnical Specifications echnical Specifications echnical Specifications GB GB GB GB Water softening unit Water softening unit Water softening unit Model Model Model A A A A A QA P QA P QA Per er er er erla la la la la QA P Water softening unit...
Page 23: Machine Log
GB GB GB GB...
Page 24 Buckinghamshire, HP12 3SU Tel: 01494 838 100 Email: sales@bwt-uk.co.uk BWT 2011 in the interests of product development we reserve the right to alter specifications without prior notice. All photographs and dimensions are given for guidance only. Terms and conditions apply E&OE.

BWT AQA Perla Installation And Operating Manual

Table of Contents

Need help?

Questions and answers

Related Manuals for BWT AQA Perla

Summary of Contents for BWT AQA Perla

Table of Contents