HearthStone Champlain 8302 Owner's Manual page 40

Hearthstone Quality Home Heating Products, Inc.
WARNING: DO NOT OPERATE THIS APPLIANCE
WITH THE GLASS PANEL REMOVED, CRACKED,
OR BROKEN. DO NOT SUBJECT THE GLASS OR
ITS FRAME TO ABUSE, SUCH AS STRIKING OR
BENDING. REPLACEMENT
PANEL SHOULD BE DONE BY A LICENSED OR
QUALIFIED SERVICE PERSON. REPLACE WITH
MANUFACTURER-APPROVED
ONLY. NE PAS UTILISER L'APPAREIL SI LE
PANNEAU FRONTAL EN VERRE N'EST PAS EN
PLACE, EST CRAQUÉ OU BRISÉ. CONFIEZ LE
REMPLACEMENT
TECHNICIEN AGRÉÉ.
NOTE: If the venting system is disassembled for any
reason, re-install per the instructions provided in the
venting section of this manual.
Annually:
Clean Firebox, Pilot, & Burner Assembly
The firebox requires periodic cleaning to prevent the
accumulation of dust, lint, and other debris. To clean
the firebox, set the switch to the "OFF" position, and
turn off the gas supply to the valve. When the unit is
cool, remove the front panel and glass (see page 9
for Firebox Access instructions) and carefully
remove the decorative ceramic log set, taking care
not to damage the logs or chip the enamel cast iron.
Remove all ember material. Clean the firebox baffle,
burner, and carefully vacuum the entire surface of
the log set with a soft brush attachment. Thoroughly
vacuum the ports (holes) along the top of the burner,
and the pilot assembly.
With the decorative ceramic logs out of the firebox,
reseal the firebox and briefly light the unit according
to the lighting instructions described on page 21.
Check to ensure a proper flame is burning from each
burner port. The pilot flame should be burning
properly as shown in figure 22.
NOTE: Do not operate the unit for more than
1-2 minutes without the log set in place.
Check and clean any burner ports that are not
burning, or not burning properly. Clean burner ports
using a soft brush or vacuum cleaner. If the pilot
flame height needs adjustment, it should be adjusted
by qualified service personnel as described on page
22.
Complete the cleaning procedure by carefully
placing the log set within the firebox as described on
pages 26-28. Reattach the glass and front panel to
seal the firebox. Turn on the gas, light the unit and
check for proper operation. Flame patterns should
look similar to the flames in Figure 34. Regularly
check to ensure the area around the Champlain is
OF THE GLASS
FRONT GLASS
DU PANNEAU À
kept free from combustible materials, gasoline, and
other flammable vapors and liquids. Check that the
flow of combustion and ventilation air is not
obstructed.
Battery Replacement
WARNING: DISCONNECT POWER TO THE UNIT
AND SHUT OFF THE GAS SUPPLY TO THE
VALVE BEFORE REPLACING ANY BATTERIES.
UN
Hearthstone recommends replacing all batteries at
least every season. Keep a supply of good quality
rechargeable
functionality during power outages, and to give the
environment a break.
Remote Transmitter Battery Replacement
You can easily change the Remote Transmitter
batteries by accessing the rear cover plate. Ensure
you orient the batteries correctly as indicated in the
battery compartment.
Receiver Battery Replacement
1. Turn the stove OFF.
2. Remove the valve access cover and set on a
non-marring surface.
3. Remove the receiver from the appliance and
remove the receiver's battery compartment
cover.
4. Install four new AA batteries. Ensure that you
orient the batteries correctly as indicated on the
battery compartment cover.
5. Slide the cover plate back onto the battery
compartment and reinstall the receiver in the
appliance.
6. Replace the access panel.
Initializing the Remote Control
You should
communication between the Receiver and the
Remote Control transmitter when you change the
batteries in either. If the system does not respond to
commands issued from the remote after changing
batteries, follow the sequence for synchronizing the
remote and transmitter described on page 31.
Professional Inspection
Installation and repair should be done by a qualified
service person. The appliance should be inspected
before use and at least annually by a qualified
Stowe 3 Model 8323
batteries on hand
not be required to
to ensure
synchronize
39