Subscribe to Our Youtube Channel
Related Manuals for Calomax Clipper 2 5L
Summary of Contents for Calomax Clipper 2 5L
- Page 1 Manuals and Documents Brought to you by Wechillit.com Ltd WCI Group House 18 Pride Hill Shrewsbury SY1 1DQ Tel: 01743 289418 Fax: 01743 289416 Web: www.wechillit.com...
- Page 2 5L, 7.5L, 10L & 15L INSTALLATION, OPERATION AND SERVICING INSTRUCTIONS Please read these instructions carefully before operating your boiler for the rst time Calomax Limited Lupton Avenue, Leeds LS9 7DD Tel. 0113 249 6681 Fax. 0113 235 0358 e-mail: service@calomax.co.uk www.calomax.co.uk...
-
Page 3: Table Of Contents
CONTENTS page INTRODUCTION INTRODUCTION Thank you for purchasing a Calomax Clipper 2 range boiler. All our products are designed to give years of simple, reliable operation. To CHECK LIST ensure this, it is important that the installation and subsequent servicing... -
Page 4: Construction
CONSTRUCTION COLD WATER INLET All metalic components of the machine, in direct contact with To comply with the U.K. Water Supply Regulation a single check- drinking water are manufactured from high quality 304 grade valve must be tted to the supply. BEFORE CONNECTING, THE stainless steel, or non ferrous materials, providing maximum SUPPLY PIPE MUST BE THOROUGHLY FLUSHED OUT TO resistance to corrosion. -
Page 5: Vent / Overflow
VENT & OVERFLOW Subsequent Use The vent / over ow pipe must be extended and laid with a continuous After the boiler has nished the commissioning cycle, and water is drawn fall, discharging to a safe and visible point. The pipe should not be from the tap, water will be replaced in short cycles (Small amount of water directly connected to a closed waste, as taste problems may occur and and then heat). -
Page 6: General Operation
0113 249 6681 CLEANING e-mail service@calomax.co.uk. or nd a local service engineer at www.calomax.co.uk Avoid using any abrasive materials. Wiping the outer casing with a damp cloth should be suf cient. Some stainless... -
Page 7: General Functions
Adjusting the Water Temperature Set Point The temperature potentiometer (Pot) is pre-set at Calomax and will only require adjustment in exceptional circumstances. Contact Calomax for advice. Water boils at different temperatures depending on barometric pressure. - Page 8 If parts required are not Exploded parts view for Clipper Range boilers identified, please contact (To be read in conjunction with the spare parts list) Calomax Limited † Includes nuts, washers, etc. 25, 26 or 27 depending on model. ††...
-
Page 9: Accessories
(with drain outlet) Swivel Nozzle attachment (Non-swivel nozzles also available - please contact Calomax for further information) Ref. SN (made to customer's dimensions) For more information visit our website at www.calomax.co.uk or call 0113 249 6681 Page 14 Page 15... -
Page 10: Spare Parts
SPARE PARTS SPARE PARTS (Refer to centre pages for location). (Refer to centre pages for location). CBTCW CBTS CBTSS UTHSG COMLPCBA CASPCBT NBPRG NBE3HK TAP CUP WASHER TAP SPRING TAP SLOTTED GREY TAP BODY PRINTED CIRCUIT LIGHT PCB PRESSURE RELIEF 3kW ELEMENT STEM HEAT SHIELD... - Page 11 Spare parts are usually available ex-stock. Please quote Model & Serial Number. BLACK YELLOW / GREEN NB15WLCPT NB10WLCPT NB: Not to scale. WATER LEVEL WATER LEVEL CONTROL PIPE FOR 10L CONTROL PIPE FOR 15L BLUE BLUE Page 18 Page 19...
-
Page 12: Trouble Shooting
BASIC TROUBLE SHOOTING SERVICE HISTORY AND NOTES Symptoms Possible Cause Remedy Broken tap top Replace tap top (or component) Normal level sensor De-scale holding signal No boiling water Thermal cut-out Reset and check for faults available tripped (no light) Element failed Replace element Excessive internal scale. -
Page 13: Warranty
SERVICE HISTORY AND NOTES WARRANTY GUARANTEE (UK Mainland customers only) Calomax have manufactured water boilers in the UK for over 50 years. We are proud of our products and the back-up service we provide Properly maintained and serviced, a Calomax boiler should last many years and we have no hesitation in providing a full 12 months parts and labour warranty for all models. - Page 14 220 - 240 V ac 50-60 Hz Power rating 3kW (MAX) Note: All measurements are approximate. PLEASE CONTACT OUR SERVICE DEPARTMENT FOR ASSISTANCE Calomax Limited, Lupton Avenue, Leeds LS9 7DD Tel: 0113 249 6681 Fax: 0113 235 0358 e-mail: service@calomax.co.uk Page 24...
Need help?
Do you have a question about the Clipper 2 5L and is the answer not in the manual?
Questions and answers