Trane IntelliPak Installation, Operation And Maintenance Manual page 100

Unit Start Up
Table 43. Service test guide for component operation — Part II of II (continued)
Component
Being Tested
Damper
FULL MODULATING
(Low Fire Adjustment)
LIMITED MODULATING
(High Fire Adjustment)
LIMITED MODULATING
(Low Fire Adjustment)
ELECTRIC HEAT
Stage 1
Stage 2
Stage 3
HYDRONIC HEAT
PRE-HEATER
OUTSIDE AIR DAMPERS
EXHAUST DAMPERS
REHEAT
Cooling Valve
Reheat Valve
Pumpout Solenoid
EVAP COND
Sump Pump
Sump Heater
Note: See Service test guide notes,
Important: Do not operate the compressors for extended periods of time without the condenser fans; high head
pressure will develop.
Table 44. Service test guide component operation—evaporative condenser
Component Being Tested
Compressors
Sump Pump
Condenser Fans
Fill Valve Relay
Drain Valve Actuator
Sump Heater
Notes:
1. Sump freeze protection is active during AUTO but is inactive in service test modes (head pressure control set to MANUAL).
2. Water treatment drain request will be ignored in service test.
100
Component Configuration
Econo Exhaust
Damper Output
Closed Closed
Closed Closed
Closed Closed
Closed Closed
Closed Closed
Closed Closed
Closed Closed
Closed Closed
Closed Closed
100% Closed
Open
100% 100%
Open
Closed Closed
Closed Closed
Closed Closed
Closed Closed
Closed Closed
p. 98.
Requirements (ON)
Sump minimum level switch must be closed for a minimum of five minutes No Requirements
Sump minimum level switch must be closed for a minimum of five minutes No Requirements
No Requirements
No Requirements
No Requirements
No Requirements
Occ
VFD Unocc Reheat
Relay
100% Unocc OFF
100% Unocc OFF
100% Unocc OFF
100% Unocc OFF
100% Unocc OFF
100% Unocc OFF
100% Unocc OFF
0% Default OFF
0% Default OFF
0% Default OFF
0% Default OFF
0% Default 100-0
0% Default 0-100
0% Default ON
0% Default OFF
100% Default OFF
Sump Sump
Dolphin
Pump Heater
OFF OFF OFF
OFF OFF OFF
OFF OFF OFF
OFF OFF OFF
OFF OFF OFF
OFF OFF OFF
OFF OFF OFF
OFF OFF OFF
OFF OFF OFF
OFF OFF OFF
OFF OFF OFF
OFF OFF OFF
OFF OFF OFF
OFF OFF OFF
ON OFF ON
OFF ON OFF
Requirements (OFF)
No Requirements
No Requirements
No Requirements
No Requirements
RT-SVX36K-EN