Section 7: Installing & Removing The Door - Montigo H38DF PRC Installation & Maintenance Manual

Section 7: Installing & Removing the Door
Removing the door:
The H*38PR* doors are removed in a few simple steps. Follow these
instructions below to remove the Horizontal access panel, unlatch the
door buckles and, remove the door. Replace in reverse order.
Remove the Horizontal Access Pan
Step 1:
Remove the Horizontal cover
by placing fingers in both finger
holes, then pushing away from
you and lifting out. Place it
aside during maintenance or
cleaning.
Install in reverse order.
Figure 24. Removing and installing the Horizontal Access Panel
Locate the Door Buckles:
Step 2:
Fixed
panel
Door buckles
Figure 24a. Locate the door buckles.
Step 3:
Release the Door Buckles
Hand-hold
Figure 24b. Door buckle Tool
Step 4:
Firmly grasp hand-hold
end of Door buckle tool
and place the machined
end in the slot under door
frame. (as shown)
Figure 24c.
XG0211 - 040912.1
Installation
Finger Holes
Installed Gas
Valve Cove r
Fixed
panel
Door Latch Slot
Door Latch Hook
1
Step 5:
Ensure the tool is firmly
in the lower end of the
slot, (as shown), Then pull
toward you (Caution: hold
el:
the tool securely).
Figure 24d.
Step 6:
Pull hard if necessary to
release the spring ten-
sion. (Caution: The latch
springs back with force,
hold the tool securely).
Figure 24e.
Step 7:
Remove the tool from
the latch slot. Ensure the
latches are hanging freely,
the hook end is released
from the bottom of the door.
(Repeat all 4-steps for the
remaining latches).
Figure 24f.
Step 8:
Grasp the Door on either side, usually midway and lift upward, lift
the door carefully up and away from the front of the fireplace. See
Figures 24g. Place the Door aside in a safe place while maintenance
and / or cleaning is being performed.
Figure 24g. Removing and installing the glass door.
To install the door, hook the top edge of the door frame into place. Lower
the door into position and follow the previous steps shown in reverse order.
H*38DF PRC Panorama Indoor Gas Fireplace
4
Removing the Door:
Installing the Door:
2
3
Page 21