Table Of Contents - Montigo H38DF PRC Installation & Maintenance Manual

H*38DF PRC Panorama Indoor Gas Fireplace
INTRODUCTION .................................................................................3
BEFORE YOU START: .......................................................................4
Section A: Before You Begin .............................................................4
Section 1: Installation Overview and Product Dimensions ..............5
Section 2: Framing the Fireplace ..................................................6 - 7
Clearances .................................................................................7
Installing the Standoffs .......................................................................7
Section 3: The Direct Vent System .............................................8 - 17
Converting from Top Vent to Rear Vent ..............................................8
Installing a Roof mounted Termination ........................................9 - 10
Venting Layout .........................................................................9 - 10
Roof mounted Terminations .......................................................9
Standard Top Vent (no elbows or offsets) ..................................9
Top Vent (two elbows one offset) ...............................................9
Top Vent (multi-elbows and offsets) ...........................................9
Standard Roof Vent (one elbows no offsets) ...........................10
Installing a Wall mounted Termination ................................. 11
▪ Standard MTO Installation ......................................................... 11
▪ Pre-installed MSR Frame .......................................................... 11
▪ Pre-installed BSR Frame ........................................................... 11
▪ Installing MOSR Frame ............................................................. 11
▪ Installing VSS Termination Shield .............................................. 11
▪ Installing MTKOG Heat Guard ................................................... 11
Venting Layout ........................................................................12 - 15
▪ Top Vent, Wall mounted Graph ..................................................12
▪ Top Vent, Wall mounted termination (one elbow) ......................12
▪ Top Vent, Wall mounted termination (multi elbow) .....................12
▪ Top Vent, Wall mounted HP38PR* Graph .................................13
▪ Top Vent, Wall mounted termination HP38PR*(one elbow) .......13
▪ Top Vent, Wall mounted termination HP38PR* (multi elbow) ....13
▪ Rear Vent, Wall mounted Graph, H*38PR* ................................14
▪ Rear Vent, Wall mounted Graph, HP38PR* ...............................15
Venting Components ....................................................................16
Heat Shields ...............................................................................17
▪ Installing a RHS8 Wall Mounted Heat Shield ........................17
▪ Installing a RHS101 Wall Mounted Heat Shield ....................17
Page 2
NOTICE
You must read and understand this manual prior to installation, operation or
troubleshooting this appliance. Please retain this owner's manual for furure reference
and maintenance.

Table of Contents

Section 4: Wiring .............................................................................18
▪ SIT Proflame gas control and pilot .........................................18
▪ SIT Nova 820 gas control and pilot ......................................18
▪ Honeywell gas control and pilot ............................................18
▪ Installing remote On/Off Wall Switch .....................................18
Section 5: Installing the Gas Line ....................................................19
Fuel Conversion ...............................................................................19
Gas Pressure ...............................................................................19
Gas Connection ...............................................................................19
Section 6: Finishing ..........................................................................20
Mantels & Surrounds ........................................................................20
Section 7: Installing & Removing the Door ......................................21
Section 8: Installing the Accessories .........................................22 - 24
Installing the Logset ..........................................................................22
Installing the HP38PR* Logset .........................................................23
Installing Firestones ..........................................................................24
Installing Optional Burner Cover Kit in Natural Gas Fireplaces .......24
Section 9: Operation .................................................................25 - 27
▪ Start-up Sequence with Standing Continuous Pilot ...................25
▪ Start-up Sequence SIT Proflame Gas valve ..............................26
▪ Start-up Sequence with Honeywell Electronic Ignition .............27
Maintenance: ........................................................................28 - 30
▪ General ...............................................................................28
▪ Cleaning ...............................................................................28
▪ Hi-Lo Burner Adjustment ............................................................28
▪ Pilot Burner Adjustment .............................................................28
▪ Troubleshooting .........................................................................29
▪ Replacement Parts ...................................................................30
........................................................................31 - 33
Appendix:
A. Venting Terminations ...................................................................31
B. Warranty ...............................................................................32
C. State of Massachusetts ................................................................33
XG0211 - 040912.1