Safety Decals - MQ Power DCA300SSJU4F3 Operation Manual

Safety decals are attached to the generator as shown in
Figure 1. Keep these safety decals clean at all times. When
the safety decals become worn or damaged, contact your
nearest dealer or the Multiquip Parts Dept.
MOVING PARTS can cause
severe injury.
DO NOT operate with doors
open.
Stop engine before servicing.
25 50 75 180 120 150
140 220 60 180 INCREASE
PSI °F RPMX10
0 100 100 260 0 210
OIL PRESS WATER TEMP SPEED
12 24 18 50 Ｅ Ｅ Ｃ Ｃ Ｃ Ｕ Ｕ Ｕ
0 VOLTS 30 0 % 100 Integrated Gauge Panel
Check ½ ½
Emissions DEF V
Failure Emissions °F °F
Failure E F E F
Needed Regen
Inhibit Regen Low Fuel FUEL DEF U
OFF
ECU
Series 800 Controller V-W
Engine Started
Shutdown
U-V
Pre-Alarm
OFF
Alarm Screen Option Program
Acknowledge Change Exit
CAUTION
DO NOT disconnect the Battery Cables
after shutting down the engine for
at least 30 seconds
DANGER
Using a generator indoors CAN KILL YOU IN MINUTES.
Generator exhaust contains carbon monoxide. This is
a poison gas you cannot see or smell.
211052 POWERED by GAC-2.2H Honda Engines 120V 15A V 120 NEUTRE MIS A LA MASSE A NEUTRAL BONDED TO FRAME AC CIRCUIT BREAKER LA CARCASSE DU MOTEUR Honda Engines POWERED by GAC-2.2H 15A 120V 120 LA CARCASSE DU MOTEUR NEUTRE MIS A LA MASSE A NEUTRAL BONDED TO FRAME V
GR PRISE DE TERRE COURANT PRINCIPAL INTERRUPTEUR DE GR PRISE DE TERRE 211052 COURANT PRINCIPAL INTERRUPTEUR DE AC CIRCUIT BREAKER
ONLY use OUTSIDE and
NEVER use inside a home
far away from windows,
or garage. Even if doors
doors, and vents.
and windows are open.
Avoid other generator hazards.
READ MANUAL BEFORE USE.
WARNING
ENVIRONMENTAL
This unit is designed to contain operating fluids only.
The environmental containment is not designed to
control fluids from an external source. It is the operator's
responsibility to monitor fluid levels at all times.
DO NOT EXCEED THE RECOMMENDED
MAXIMUM CAPACITY
Figure 1. Safety Decals
PAGE 4 — DCA300SSJU4F2/F3 60 HZ GENERATOR • OPERATION MANUAL — REV. #2 (04/18/22)
WARNING
HOT COOLANT can cause
severe burns.
Do not remove cap if
radiator is hot.
M9503000004
WARNING
ARC FLASH AND SHOCK HAZARD
Appropriate PPE Required
Appropriate Personal Protection
Equipment and Tools Required
when working on this equipment.
M92010070
DECREASE
W
W-U
M90130000
WARNING
ELECTRIC SHOCK HAZARD
Do not touch internal wiring
or connections while this
machine is operating.
Turn power off before
servicing.
M92010000
Operation of this equipment may create
sparks that can start fires around dry
vegetation.
A spark arrestor may be required.
The operator should contact local fire
agencies for laws or regulations
relating to fire prevention requirements.
M9504200004
211052 GR PRISE DE POWERED by GAC-2.2H Honda Engines 15A 120V V 120 COURANT PRINCIPAL AC CIRCUIT BREAKER NEUTRAL BONDED TO FRAME INTERRUPTEUR DE NEUTRE MIS A LA MASSE A LA CARCASSE DU MOTEUR
TERRE
M90320010
25 50 75 140 180 220 120 150 180
0 PSI 100 100 °F 260 60 0 RPMX10 210
OIL PRESS INCREASE DECREASE
12 18 24 WATER TEMP 50 Ｅ Ｅ Ｃ Ｃ Ｃ Ｕ Ｕ Ｕ SPEED
Check 0 VOLTS 30 ½ 0 % 100 ½ Integrated Gauge Panel
DEF Emissions Failure °F °F
Regen Failure Needed Emissions E F E F V
Regen Inhibit Fuel Low FUEL DEF
U W
ECU OFF
Series 800 Controller Engine Started
Shutdown V-W
Pre-Alarm
U-V W-U
OFF
Alarm Screen Option Program/
Acknowledge Change Exit
P/N M91110000
D D e e n n y y o o
FRONT VIEW
NOTICE
For safety decal part numbers, reference parts manual.
CAUTION
WARNING
Maximum capacity of lifting
bail is 19,000 lbs.
M90310000
TOP VIEW
CAUTION
HOT PARTS can burn skin.
DO NOT touch until the
machine has sufficiently
cooled.
SIDE VIEW
CAUTION
This machine stops and starts automatically
and without notice.
M92010060
300
DANGER
HIGH VOLTAGE
S-2731
WARNING WARNING
ELECTRIC SHOCK HAZARD ELECTRIC SHOCK HAZARD
Do not touch output Always complete the grounding
terminals while this path from the ground terminal
machine is operating. on the genset to an external
grounding source.
Turn power off before
servicing.
See instruction manual for
details.

SAFETY DECALS

D
M55100080
No Diesel
M911010000 REAR VIEW
300
CAUTION
This machine stops and starts automatically
and without notice.
CAUTION
Ensure the "Auto-Off/Reset-Manual" switch is
in the "Off/Reset" position. If it is not, when
the battery cables are connected, the engine
will crank and attempt to start.
WARNING
ELECTRIC SHOCK HAZARD
Do not touch internal wiring
or connections while this
machine is operating.
Turn power off before
servicing.
M92010000
SIDE VIEW
WARNING
Before connecting this generator to any building's
electrical system, a licensed electrician must install
an isolation (transfer) switch.
Serious injury or death may result without this
transfer switch.
M92010050
CAUTION
EXHAUST FLUID ONLY
Filling this tank with
anything other than
DIESEL EXHAUST FLUID
may result in severe
engine damage.
M94110000
M92010060
M91010040
WARNING
ENGINE EXHAUST can cause
severe injury or death.
Use only in open, well
ventilated areas or
vent exhaust outside.
M9503200004