Safety Decals - MQ Power WHISPERWATT Series Operation Manual

SAFETY DECALS

Safety decals are attached to the generator as shown in
Figure 1 . Keep these safety decals clean at all times. When
the safety decals become worn or damaged, contact your
nearest dealer or the Multiquip Parts Department.
WARNING
MOVING PARTS can cause
severe injury.
DO NOT operate with doors
open.
Stop engine before servicing.
RADIATOR
Operation of this equipment may create
sparks that can start fires around dry
vegetation.
A spark arrestor may be required.
The operator should contact local fire
agencies for laws or regulations
relating to fire prevention requirements.
WARNING
ARC FLASH AND SHOCK HAZARD
Appropriate PPE Required
Appropriate Personal Protection
Equipment and Tools Required
when working on this equipment.
WARNING
ENVIRONMENTAL
This unit is designed to contain operating uids only
The environmental containment is not designed to
control uids from an external source. It is the operator's
responsibility to monitor uid levels at all times.
DO NOT EXCEED THE RECOMMENDED
MAXIMUM CAPACITY
DANGER
Using a generator indoors CAN KILL YOU IN MINUTES.
Generator exhaust contains carbon monoxide. This is
a poison gas you cannot see or smell.
POWERED by GAC-2.2H 120V 15A 120 V LA CARCASSE DU MOTEUR NEUTRE MIS A LA MASSE A NEUTRAL BONDED TO FRAME GAC-2.2H 15A 120V V LA CARCASSE DU MOTEUR NEUTRAL BONDED TO FRAME NEUTRE MIS A LA MASSE A 120
GR PRISE DE TERRE 211052 Honda Engines INTERRUPTEUR DE AC CIRCUIT BREAKER COURANT PRINCIPAL TERRE GR PRISE DE 211052 POWERED by Honda Engines COURANT PRINCIPAL INTERRUPTEUR DE AC CIRCUIT BREAKER
ONLY use OUTSIDE and
NEVER use inside a home
far away from windows,
or garage. Even if doors
doors, and vents.
and windows are open.
Avoid other generator hazards.
READ MANUAL BEFORE USE.
DANGER
HIGH VOLTAGE
WARNING
ELECTRIC SHOCK HAZARD
Do not touch output
terminals while this
machine is operating.
Turn power off before
servicing.
PAGE 4 — DCA40SSKU4F2 60 HZ GENERATOR • OPERATION MANUAL — REV. #2 (08/30/22)
M90300000
M90420000
M92010070
M91110000
GAC-2.2H 120V V 120 NEUTRAL BONDED TO FRAME
211052 Honda Engines POWERED by 15A LA CARCASSE DU MOTEUR NEUTRE MIS A LA MASSE A INTERRUPTEUR DE AC CIRCUIT BREAKER
GR PRISE DE TERRE COURANT PRINCIPAL
FRONT VIEW
M90320010
CAUTION
This machine stops and starts automatically
and without notice.
M92010060
40
SIDE VIEW
M92010040
WARNING
ELECTRIC SHOCK HAZARD
Before connecting this generator to any building's
Always complete the grounding
electrical system, a licensed electrician must install
path from the ground terminal
an isolation (transfer) switch.
on the genset to an external
grounding source.
Serious injury or death may result without this
See instruction manual for
transfer switch.
details.
Figure 1. Safety Decals
NOTICE
For safety decal part numbers, refer to the associated
parts manual.
WARNING
CAUTION
HOT COOLANT can cause
Maximum capacity of lifting
severe burns.
bail is 5,150 lbs.
Do not remove cap if
radiator is hot.
M90310000
TOP VIEW
M91020000
WARNING
ENGINE EXHAUST can cause
severe injury or death.
Use only in open, well
ventilated areas or
vent exhaust outside.
CAUTION
WARNING
Ensure the "Auto-Off/Reset-Manual" switch is
in the "Off/Reset" position. If it is not, when
the battery cables are connected, the engine
will crank and attempt to start.
M92010050
SAFETY DECALS
M15000150
CAUTION
Stop engine before
switching.
M92010020A
CONTROL BOX
(Right-Side)
ECU R
Intergrated Gauge Control
Low Oil Pressre
A
High temp. V-W
B
Over Crank
C Over Speed
U-V
Engine Started
D
E
OFF
F
INCREASE DECREASE
WARNING:
ECU TERMINAL
HIGH VOLTAGE
M92110000
HOT PARTS can burn skin.
DO NOT touch until the
machine has sufficiently
M90320000
cooled.
SIDE VIEW
CAUTION
This machine stops and starts automatically
and without notice.
M91010040
W-U
WARNING
ELECTRIC SHOCK HAZARD
Do not touch internal wiring
or connections while this
machine is operating.
Turn power off before
servicing.
M92010000
CAUTION
M91010000
40
M92010060